2012 Mazda CX-9 Complaints

The contact owns a 2012 Mazda CX9. The contact stated that the vehicle had previously been involved in a crash due to a fractured passenger's side lower control arm. The dealer was made aware of the failure and confirmed that the vehicle had been repaired under NHTSA Campaign Number: 15V451000 (Suspension). The dealer referred the contact to the manufacturer for assistance. An independent mechanic replaced the passenger's side lower control arm; however, the contact stated that after the repair was performed, the engine rattled and the vehicle stalled. The vehicle was then taken back to the independent mechanic, who determined that the driver's side lower control arm spacers were missing and that the front and rear axles, brakes, and rear shocks needed to be replaced. Additionally, the cage bolts needed to be retightened. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 110,000.

The contact owns a 2012 Mazda CX-9. The contact stated that on several occasions while driving at various speeds, the front passenger’s side seat belt was tightening intermittently causing discomfort for the front seat passenger. There was no warning light illuminated. The vehicle had not yet been taken to an independent mechanic or a local dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 175,000.

On August 14, 2020, the brake booster along with the master cylinder failed, resulting in very dangerous and frightening driving conditions, and the parts were replaced with Mazda original parts. This was an ongoing issue with the Mazda CX-9’s. I reported it to the NHTSA, complaint number 11480067. On January 4, 2023, the brake master cylinder and booster failed again resulting again in very dangerous and frightening driving conditions. The car was driven only 25,383 miles before the brakes failed the second time. The Mazda parts were defective and continue to be so after many years with no effort by Mazda to improve these parts. Attached are the repair invoices for both incidents. I have tried contacting Mazda and they refuse to address the issue.

After hearing low rumbling sound and smelling burnt oil, car was taken to dealer for check up. They informed me of known issue, front PTU leaking oil due to design flaw that put the PTU so close to the exhaust. I am seeing that other owners of this model are also reporting fires due this same exact problem, apparently unbeknownst to me Mazda has provided extended warranty up to 90k miles but not actually informed the owners of this as a potential catastrophic problem. my personal review has informed me that fire seem to be most common between 110,000 and 130,000 mile ranges.

The brakes suddenly became very difficult to press as if I did not have power brakes. No warning lights came on and it became very difficult to stop the car. Then if I had to break suddenly and hard it would stall. I brought it to the repair shop and the brake booster was defective. The brake booster along with the master cylinder had to be replaced. It was a very dangerous and frightening experience the brakes suddenly difficult to use. I contacted Mazda customer service and they did not care. I then tried to escalate the issue over the last two years but it was impossible to contact anyone and all emails came back undeliverable. I just recently learned that I can report this danger to the NHTSA.