2013 Hyundai Veloster Complaints

On or about May 1, 2025, I was operating my 2013 Hyundai Veloster when flames were observed emanating from under the hood. I immediately pulled into the median and, upon opening the hood, observed an active fire beneath the plastic engine cover. I contacted 911. Before the fire department arrived, a passerby extinguished the flames with a fire extinguisher. Firefighters from a nearby station arrived shortly thereafter and fully doused the engine compartment. The vehicle was subsequently towed to a Hyundai dealership. At that time, I was aware of an active recall related to potential brake line issues that could result in an engine compartment fire. After the vehicle remained at the dealership for an extended period, I was informed that Hyundai Motor America (“HMA”) would send an inspector. Approximately 30 days later, I was contacted by HMA’s corporate office and asked to provide documentation, including a copy of the title and insurance information. During this call, I was advised tha...

Smoke, burning smell came from ac control unit. Ac wiring unit, knob completely burned/melted. Reported to Hyundai local and corporate office no resolution other then I just have to replace the unit. Please note this happened in 2022 (40,000 miles today vehicle had 58,000miles) and I paid in full for the replacement the 1st time.

While driving under normal conditions at approximately 65 mph, the engine emitted a sudden “bang” and severe knock. Over the following week, the vehicle stalled several times. Inspection revealed one piston crown was chipped, which then scored the cylinder wall and caused an oil leak. No other pistons or bearings showed wear. This failure pattern is consistent with low‐speed pre-ignition events documented in numerous online owner reports—many describing identical piston or rod breakage in 2013–2015 Veloster Turbos under Recall 19V204000, which addresses exactly this defect. The vehicle was partially disassembled for inspection, and Hyundai dealers have refused to perform the federally mandated Recall 19V204000 remedy. Instead, they deceptively insist on treating this as a warranty work request—despite me having told them more than five times (on multiple recorded calls), in two portal updates, and via certified letters, that this is a safety recall issue, not a warranty claim. Their re...

Vehicle Info: 2013 Hyundai Veloster VIN: [XXX] Odometer: 75,000 miles Problem Description: My check engine light began flashing and the vehicle entered limp mode. Diagnostic codes showed P1326 and U1103, which are linked to a known Theta II engine defect involving rod bearing failure. Hyundai issued a 15-year / 150,000-mile warranty extension and settled a class-action lawsuit to cover these failures. However, my request for coverage was denied due to “time in service” despite being well below the mileage limit (only 75k miles). This is a serious safety concern that may result in sudden engine failure. I am requesting that NHTSA investigate Hyundai's denial and handling of such cases INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2013 Hyundai Veloster (VIN: [XXX] ) has the known P1326 fault related to the Theta II engine defect. Despite a rod bearing test that passed, the engine now requires replacement, confirmed by the dealer, who quoted me $8,494. Hyundai refuses to assist, even though I am under the 150,000-mile extended warranty. This is a safety risk and fits the class-action defect criteria. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)