2017 Ford F-550 Complaints

The contact owns a 2017 Ford F-550. The contact stated that after two to three minutes after the engine was idled, a ticking noise was heard in the engine. The noise would dissipate however, a rattling noise was heard next. The contact stated works as an independent mechanic and diagnosed the vehicle and stated that the #3 cylinder had a low oil pressure and that the camshaft and follower needed to be replaced. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 213,720.

National Traffic and Motor Vehicle Safety Act of 1966 (Safety Act), S571.120 Tire/Rim Selection, S5.1.2, requires the sum of the maximum load ratings of the tires fitted to the axle shall be not less than the gross axle weight rating (GAWR) of the axle system specified on the vehicle's certification label required by 49 CFR part 567. 567.77 requires any alterer of the vehicle to continue conformity with these requirements and assumes legal liability for certification under the Safety Act. The Siberian RV (see pic) is a customized off-road expedition vehicle manufactured by ProVan Industries, West Columbia South Carolina. They utilize a Ford F550 Super Duty 4x4 as the chassis and customize the RV to travel into off-grid extreme environments and road conditions. ProVan alters the standard Ford F550 dual rear wheel to a single rear wheel. The altered Certification Label affixed to the vehicle (see pic) establishes the rear axle GAWR at 14,706 pounds. The Tire/Wheel (Rim) assembly chosen...

National Traffic and Motor Vehicle Safety Act of 1966 (Safety Act), S571.120 Tire/Rim Selection, S5.1.2, requires the sum of the maximum load ratings of the tires fitted to the axle shall be not less than the gross axle weight rating (GAWR) of the axle system specified on the vehicle's certification label required by 49 CFR part 567. 567.77 requires any alterer of the vehicle to continue conformity with these requirements and assumes legal liability for certification under the Safety Act. The Siberian RV (see pic) is a customized off-road expedition vehicle manufactured by ProVan Industries, West Columbia South Carolina. They utilize a Ford F550 Super Duty 4x4 as the chassis and customize the RV to travel into off-grid extreme environments and road conditions. Provan alters the standard Ford F550 dual rear wheel to a single rear wheel The altered Certification Label affixed to the vehicle (see pic) establishes the rear axle GAWR at 14,706 pounds. The Tire/Wheel (Rim) assembly cho...

TL* THE CONTACT OWNS A 2017 FORD F-550. THE CONTACT STATED WHILE DRIVING AT UNDISCLOSED SPEEDS, THE VEHICLE FAILED TO DRIVE IN A STRAIGHT LINE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER FREEWAY FORD TRUCK SALES (8445 45TH ST, LYONS, IL 60534, (708) 442-9000) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

FORD PUT A 2 RUBBER BRAKE HOSES WITH OUTER BRAIDED STEEL OUTER CASING ON THE BUILD AROUND THE A.B.S. UNIT ON THE DRIVER SIDE ENGINE COMPARTMENT. ONE OF THESE HOSES FAILED INSTANTLY RESULTING IN A LOW SPEED COLLISION WITH NO BRAKES.WITH NO PREVIOUS WARNING OF ANY KIND IE SOFT PEDAL ETC. NO KIND LIGHT CAME ON. THIS MUST BE CORRECTED BEFORE THIS STARTS HAPPENING ALL OVER THE U.S.A. THE TRUCK IS BEING REPAIRED AT AN AUSTIN,TX FORD DEALER WITH THE SAME PART THAT JUST HAD A CATASTROPHIC FAILURE. THE HOSE SHOWS NO RUBBING OR OUTSIDE CONTAMINATION IE DIRT DEBRIS ETC. THE CRASH HAPPENED AT ABOUT 30 MPH, AND MODERATE BRAKING.