-
Electrical System
05/01/2015
TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY SHUT OFF AND ON SEVERAL OCCASIONS WOULD NOT START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DETERMINED THAT THE FUEL INJECTION CONTROL MODULE WIRE HARNESS NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER, WHO EXPLAINED THAT THE HARNESS WAS REPLACED IN 2005 UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 83,000.
-
Service Brakes
08/02/2015
WHILE APPLYING BRAKES IN AN ATTEMPT TO STOP, THE BRAKE PEDAL UNEXPECTEDLY WENT DIRECTLY TO THE FLOOR, THUS DISALLOWING THE TRUCK TO STOP. THE PEDAL WAS ABLE TO BE PUMPED,UP ENOUGH IN ORDER TO STOP THE TRUCK, BUT ONLY ONE TIME. ATTEMPTS TO PUMP THE PEDAL AND INCREASE THE PRESSURE ENOUGH FOR FUTURE ATTEMPTS AT STOPPING THE TRUCK WERE UNSUCCESSFUL. INSPECTION OF THE VEHICLE BY CERTIFIED MECHANICS REVEALED RUST BUILDUP ON/NEAR A WEAK SPOT ON ONE OF THE BRAIDED, FLEXIBLE FRONT BRAKE LINES WHICH HAD BURSTED, VIRTUALLY MAKING THE BRAKES USELESS BY DISALLOWING PRESSURE TO BE BUILT UP IN THE SYSTEM. A FURTHER INSPECTION OF THE SYSTEM REVEALED A SECOND BRAIDED, FLEXIBLE BRAKE LINE THAT WAS SHOWING SIGNS OF RUST BUILDUP AND EMINENT FAILURE. THE POINT OF FAILURE ON BOTH LINES WAS THE FLEXIBLE, BRAIDED SECTION ITSELF, JUST ADJACENT TO WHERE IT CONNECTED WITH THE PRE-MOLDED PORTION OF EACH LINE.
-
Steering
04/20/2015
TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE POWER STEERING FAILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
-
Engine
02/05/2015
TL*THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT OIL WAS LEAKING FROM THE HEAD GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 210,000.
-
Engine
10/13/2014
TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 37,237.
