2022 Ford Bronco Sport Complaints

I've had a Blindspot warning light alert, told by dealership this is an electrical issue, after a web search, I see this is a common and known issue for Ford, yet no recall has been issued. I also have another know, common powertrain issue with my rear differential. The vehicle makes noise when turning, unstable when driving. The vehicle is less than 5yrs old and under 60k miles. Both issues are safety issues and could cause an electrical fires or vehicle stalling. I am scheduled for a 2nd inspection on 7/31 and hopefully repair.

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that exhaust fumes were entering the cabin of the vehicle. The contact stated that the dealer had previously installed a fuel injector tube behind the front driver's side wheel. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that parts were not yet available. The failure mileage was approximately 68,000.

Vehicle was parked in a parking lot. When starting the vehicle and trying to put it into reverse, it would not backup. Vehicle had to be towed to the dealership. The transmission had gears stripped and was due to a failure of the shift module of the vehicle. The vehicle had under 67,000 miles on it. There were no issues with the shift module or transmission up until this point.

Vehicle developed a hum when accelerating on July 5, 2026. Made an appointment with the dealership to have it diagnosed. They could not get me in until July 16, 2026. On July 15, 2026, the vehicle went into limp mode and had to be driven at an unsafe speed to the dealership to diagnose and repair the issue. There are 81,000 miles on the vehicle. The issue turned out to be a cracked catalytic converter. The catalytic converter had previous been replaced in August 2025 due to the same issue at 67,000 miles.

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The local dealer was contacted and confirmed that parts were not yet available for the recall repair. The dealer informed the contact that the manufacturer would notify vehicle owners whenever the part became available. The manufacturer was not contacted. The contact had not experienced a failure.