-
Power Train
08/21/2002
VEHICLE WILL NOT RUN PROPERLY DUE TO THE TRANSFER CASE BEING DEFECTIVE. THERE IS A LOUD NOISE WHEN DRIVING. CONTACTED DEALER, AND THE DEALER NOTED THAT VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK *YH
-
Suspension, service Brakes, Hydraulic
01/16/2002
RIGHT FRONT SPINDLE AND KNUCKLE ASSEMBLY MALFUNCTIONED. DEALER HAS BEEN NOTIFIED. *AK RIGHT FRONT SPINDLE/KNUCKLE ASSEMBLY WAS REPLACED. RIGHT FRONT ROTOR, INNER AND OUTER WHEEL BEARINGS AND SEAL WERE ALL REPLACED. *TT
-
Air Bags
12/01/2001
VEHICLE WAS IN A HEAD-ON COLLISION AND NEITHER OF THE AIR BAGS DEPLOYED. PLEASE PROVIDE MORE INFORMATION.*AK
-
Service Brakes, Hydraulic, power Train
11/17/2001
FORD RECOMMENDS INCORRECT ADJUSTMENT OF REAR BRAKES, WHICH CAUSES OVERHEATING OF DRUMS AND EVENTUAL FAILURE OF AXLE SEALS, AXLE BEARINGS, AND TIRE ON THE RIM ATTACHED TO THE BRAKE DRUM. FORD STIPULATES THAT BRAKE SHOES ARE TO BE TOUCHING DRUM WHEN BRAKES ARE ADJUSTED. THIS RESULTS IN FRICTIONAL HEAT BUILD-UP, AND IS LIKELY TO BE A CONTRIBUTOR TO TIRE FAILURES REPORTED WITH THE FORD EXPLORER. THE FORD EXPLORER, AEROSTAR, AND RANGER ALL SHARE POWER TRAIN AND DRIVE TRAIN COMPONENTS. THIS PRACTICE HAS COST ME $000S ON MY 4 FORD AEROSTARS (1989, 1992, 1994, AND 1997 MODEL YEARS)
-
Air Bags
06/22/2001
VEHICLE WAS SLOWING DOWN GOING 35-45MPH IN THE RIGHT SLOW LANE. WHEN BRAKES WERE APPLIED, VEHICLE PICKED UP MORE SPEED, CAUSING CONSUMER TO LOSE CONTROL. VEHICLE RAN INTO ONE OF THE BEAMS UNDER UNDERPASS OF THE HIGHWAY. UPON IMPACT, FRONT DRIVER'S AIR BAG DIDN'T DEPLOY. CONSUMER'S FACE HIT STEERING. CONSUMER HAD 16 STICHES IN BOTTOM LIP. CONSUMER HAD A CASE, AND WAS NOT ALLOWED TO CONTACT DEALER AT THIS TIME.*AK
