1997 Dodge Dakota Complaints

TL*THE CONTACT OWNS A 1997 DODGE DAKOTA. UPON STARTING THE VEHICLE, THE CONTACT NOTICED A STRONG FUEL ODOR. THE CONTACT SHUT THE VEHICLE OFF AND DISCOVERED FUEL LEAKING UNDER THE VEHICLE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 120,000. UPDATED 02/03/11*LJ UPDATED 03/17/11

DUE TO POOR CHOICE OF MATERIALS (I ASSUME) THE FRONT HUB AND SPINDLE ASSEMBLY WEARS. LEAVING FRONT BRAKE SLIDER PINS UNATTACHED TO CALIPER MOUNTING PLATE. WHEN THIS HAPPENS, THE FRONT CALIPER WOBBLES IN IT'S PLACE, POSSIBLY EJECTING THE SLIDEPINS BECAUSE THEY "WOBBLE" IN THE KNUCKLE HOLES DESIGNED TO RETAIN THEM. THIS CAUSES EXCESS WEAR ON THE FRONT HUB ASSEMBLY, INCREASED WEAR IN BRAKES, AND STRESS ON THE HUB BEARINGS. HAVING READ THE "ALLDATA" DATA BASE, THERE IS A REDESIGNED KNUCKLE WITH IMPROVED SLIDE PIN SUPPORTS. THERE ALSO IS A REPAIR KIT INVOLVING THE USAGE OF "HELI-COIL" INSERTS TO SECURE BRAKE PAD CARRIER TO SPINDLE ASSEMBLY. (SLIDE PINS) I FEEL TOTALLY UNSAFE WITH THIS ARRANGEMENT. I PREFER TO HAVE THE RE-DESIGNED SPINDLE ASSEMBLIES INSTALLED FOR FREE BY DEALER WITH UP-DATED PART NUMBERS. THE DEALER WANTS $1000 PER SIDE FOR THE REDESIGNED UNITS. I THINK THIS IS ABSURD. THIS IS A SAFETY HAZARD AND COULD CAUSE LOSS OF LIFE DUE TO LOSS OF CONTROL. THE ONLY THING HOLDING THE BR...

TL*THE CONTACT OWNS A 1997 DODGE DAKOTA. THE VEHICLE HAS CONTINENTAL TIRES. WHILE DRIVING 65 MPH, THE TREAD FROM ONE OF THE TIRES BEGAN TO STRIKE THE DOOR AND FRONT FENDER OF THE VEHICLE BEFORE COMPLETELY SEPARATING FROM THE TIRE. THE REMAINDER OF THE TIRES REMAINED INFLATED. THE CONTACT DID NOT DRIVE OR ANY POTHOLES OR OTHER ROAD HAZARDS TO CAUSE THE FAILURE. HE TOOK THE TIRE BACK TO THE STORE FROM WHERE IT WAS PURCHASED AND WAS INFORMED THAT IT WAS DEFECTIVE. THE TIRE WAS REPLACED FOR FREE. THE TIRE SIZE, TIRE LINE, AND REMAINING TREAD DEPTH WERE UNKNOWN. THE FAILURE MILEAGE WAS 90,408. UPDATED 03/17/09. *LJ THE CONSUMER BELIEVED THE TIRE WAS DEFECTIVE. UPDATED 03/17/09. *JB

THE BALL JOINTS ON MY 97 DODGE DAKOTA ARE WORN OUT. APPARENTLY THIS IS A VERY COMMON PROBLEM AND SUPPOSEDLY THERE IS A RECALL IN EFFECT FOR NEWER DAKOTAS AS THOUGH THE PROBLEM DIDN'T START UNTIL AFTER 1997. THIS IS A FAULTY PART FROM THE MANUFACTURING PROCESS AND ITS REPAIR (AMONGST THE MANY OTHER MANUFACTURING FAULT REPAIRS ON THIS VEHICLE) IS RUINING ME FINANCIALLY IN THIS ECONOMY. I SHOULD NOT BE HELD FINANCIALLY RESPONSIBLE FOR A CAR MAKERS INEPT MANUFACTURING. *TR

THE FRONT BRAKE CALIPER BOLTS TO THE STEERING KNUCKLE ON A 1997 DODGE DAKOTA, 4WD. DUE TO THE NATURE OF THE DESIGN, THE THREADS THAT HOLD THE BRAKE CALIPER MOUNTING STUDS CAN STRIP OUT, THEREBY LEAVING THE CALIPER TO FLOAT ON THE KNUCKLE. UNDER PROLONGED USE, THESE STUDS CAN BACK OUT, LETTING THE CALIPER FALL OFF, WHICH COULD LEAD TO A CRASH. ON MY PARTICULAR VEHICLE, THIS HAS HAPPENED FOR THE THIRD TIME NOW, ONCE ON THE DRIVER'S SIDE AND TWICE ON THE PASSENGER SIDE. THE THREADS STRIP OUT, AND THE MOUNTING BOSS SECTION IS SO SMALL THAT A LARGER THREAD CANNOT BE RETAPPED WITHOUT DANGER OF BREAKING THE HOLE OUT. AUTO PARTS SUPPLIERS SELL SLIGHTLY OVERSIZE, SELF TAPPING STUDS, BUT THESE DO NOT LAST LONG. THE STEERING KNUCKLE IS A VERY PRICEY PART (ON THE ORDER OF $600 JUST FOR THE PART) AND CONTINUING REPLACEMENT IS COST PROHIBITIVE. MY VEHICLE IS APPARENTLY NOT THE ONLY ONE WITH THIS PROBLEM, AS A SEARCH OF SALVAGE YARDS REVEALED NUMEROUS STRIPPED OUT THREADS ON VEHICLES WHERE THE STEER...