2022 Chevrolet Tahoe Complaints

My 2022 Chevrolet Tahoe has a recurring pattern of excessive oil consumption, smoke from the exhaust, repeated check engine light events, P0420 catalyst-efficiency faults, and repeated catalytic-converter-related repairs. At approximately 75,000 miles, the vehicle shut down on the freeway. At approximately 121,000 miles, the first catalytic converter failed. Chevrolet of Wesley Chapel documented P0420 and catalyst failure in November 2025, and GM service history reflects catalytic-converter replacements at 131,468 miles and approximately 141,082 miles. The vehicle also underwent major injector-related repair in early 2026. At 141,620 miles, Chevrolet of Wesley Chapel started an oil consumption test and stated in writing that oil consumption can lead to repeat failed converters and false oxygen sensor readings. Despite substantial repairs, the problem pattern continued. I am reporting this as a possible safety-related defect affecting engine operation, emissions-system failure, and driv...

The contact's wife owns a 2022 Chevrolet Tahoe. The contact stated that while driving approximately 50-60 MPH, several unknown warning lights illuminated. The driver pulled over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that unknown engine valves had collapsed, and there was possible camshaft damage. The contact was advised that further diagnostic tests were required. The dealer informed the contact that a recall should be issued for the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was referred to the dealer for assistance. The failure mileage was approximately 68,000.

Driving down I495 in Mass when engine stopped with no warning or prior symptoms. My wife and 4 children (including 2 friends of our kids) were in the car. Luckily we were able to safely pull to the shoulder after coasting through a construction zone. If we hadn’t made it to a safe piece of shoulder chances are high that another vehicle would have hit our vehicle and hurt and killed us. These 6.2 engines are a serious safety hazard and I only hope my new engine proves to be reliable. Car was towed to dealer who diagnosed it as a seized motor. Car is a 2022 Chevy Tahoe with the problematic 6.2 engine. Engine had passed Chevrolet’s Pico test as per the 6.2 recall about 7,000 miles before it seized. Vehicle and engine dealer maintained with all required changes/maintenance. Engine seized/failed with no warning.

The vehicle shifted itself into neutral and shut off while driving. It happened twice in three days. The first time I was pulling into the driveway so I was able to put it in park and restart the car safely. The second time I was in the middle of traffic in Tampa and it shifted into neutral and shut off in the middle of the road. Luckily no cars hit me but again I had to apply the break , restart the car and put it back in drive. This was very scary and I had my kids with me. Earlier in the day I had been driving on 75 and if it had happened then it could have been a bad wreck. It shows there are no current recalls on my vehicle. No warning lights or messages appeared. Vehicle was purchased less than 30 days ago. I will contact the dealership to verify there are no open recalls just in case but again when I checked I found none.

The contact owns a 2022 Chevrolet Tahoe. The contact stated that while driving at various speeds, the contact became aware that the driver's side rearview mirror was pointing upwards or downwards, reducing the driver's ability to see the roadway. The driver's side rearview mirror had been making unintended movements while starting the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 33,000.