2020 Chevrolet Tahoe Complaints

I own a 2020 Tahoe, 160,000 miles. While driving, the vehicle experienced a sudden loss of brake assist due to a failure of the vacuum brake pump. The brake pedal became extremely hard, and the vehicle would not slow or stop as expected, requiring me to put vehicle in neutral and frantically find a way to the shoulder to force a stop (pulling the emergency brake). This created a dangerous condition and significantly increased stopping distance, posing a serious safety risk to myself, and others on the road. There was little to no warning prior to the failure. This issue appears to be consistent with known complaints involving vacuum pump failure and loss of brake assist in similar vehicles. A failure of the braking assist system is NOT a normal wear condition and presents a critical safety hazard. I am reporting this incident due to the safety risk associated with sudden brake assist failure and the potential for accidents or injury. Vehicle issue has been confirmed by an indepen...

The air conditioning system fails to cool. My vehicle only has 47,000 miles on it currently and is well-kept. A professional garage inspected and advised that there was a leak in the refrigerant system. I contacted my local Chevrolet dealer Jeff Gordan Chevrolet where I purchased the vehicle new and they said the issue was not under warranty and that my warranties had expired. They would not repair the air conditioning system at no cost to me, the owner.

On June 17th, 2025 while driving from [XXX] back to my home state of [XXX] , I experienced an engine malfunction in Chester, Va where the 6.2 L87 engine was shaking and had severe hesitation. It was diagnosed by the Chevrolet dealership in Chester, VA as suffering severe failure of ALL 8 fuel injectors, fuel rails and connector harnesses, resulting in a 15 day repair wait and a $4,644.50 bill not including other expenses such as lodging/car rental. At this time my vehicle had 52,182 miles. After this I attempted for 3 months for GM to cover the repair as the vehicle was less than 5 years old and less than 60,000 miles under the 5 yr/60K warranty but denied it. On March 26th, 2026 while driving on the parkway at about 60 mph, my vehicle experienced loss of power (slow deceleration, shaking/hesitation) and I immediately took it to the repair shop where it was diagnosed as a P0308 code (misfire on cylinder 8) which caused a repair of the #8 spark plug, ignition coil and wire resulting in...

Suddenly lost all power steering, then warning power steering attention, no control for steering, very dangerous, couldn't drive vehicle. Took independent car repair to fix. $5k repair to fix problem. Should not happen to vehicle.

Lifter failed on my Chevy Tahoe 6.2L engine at ~75K miles in September 2025. One lifter bank was replaced. No reason for lifter failure was given. Less than 5 months later the other lifter bank has failed and damaged the cam shaft. Again, no reason for failure was provided. Failed lifters can cause catastrophic engine failure, which is incredibly dangerous when the vehicle is in motion. No check engine lights or and warnings occur with the lifter failure, it is only identified by the driver through the tapping noise from the engine. Even a cursory review of forums and complaints reveals that lifter failure is widespread on this engine and that manufacturing defects have caused issues with this power train dating back to 2019, not just the recalled 2021-2024 models.