2020 Chevrolet Sonic Complaints

Engine Cooling System (Thermostat Housing / Water Outlet) The vehicle suffered a premature structural failure of the factory engine coolant thermostat housing. The component, which is manufactured from a fragile plastic composite, cracked completely open without warning, causing an immediate, rapid loss of engine coolant. This constitutes a severe safety hazard. A sudden, catastrophic loss of engine coolant under normal driving conditions puts the vehicle at immediate risk of severe engine overheating and sudden engine stalling or seizure while in motion. If the engine stalls unexpectedly in high-speed traffic, it strips the driver of power steering and braking assistance, drastically increasing the risk of a serious collision. General Motors is fully aware of this pervasive material defect across the Chevy Sonic model years, yet they refuse to issue a safety recall, forcing owners to operate vehicles with inherently flawed, dangerous plastic cooling components. They also refuse to h...

Purchased from Carvana. Nine days after purchase came out to a dead battery took it to the authorized dealer and they said the battery was a bad cell battery. Replace the battery. Six days after they replaced the battery it was dead again. This time they had it in the shop for two weeks before they found the issue. It had been aftermarket wired with a GPS tracking system that was draining the battery. They said if I have any further issues with it, I need to take it to a dealer. They gave me a bag full of multiple components that had been added to the vehicle. I do not know how Carvana missed them all.

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The passenger seat adjustment mechanism has failed, causing the seat to become stuck in the farthest rear position. The malfunction is likely related to either the motor, seat track, or the electrical system controlling the adjustment. The seat is available for inspection. 2. How was your safety or the safety of others put at risk? The stuck seat presents a safety hazard because it is positioned too far back, which can prevent proper seating posture or seatbelt positioning for a passenger. This could increase the risk of injury in the event of a crash, as the passenger may not be secured properly or may be too far from the airbag deployment zone. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the issue has been confirmed by both an independent mechanic and two other individuals knowledgeable about cars. The problem has been physically in...

Having trouble with leaks and the evap purge system. I repaired it three times. The vehicle will turn off while driving.

1st occurence at approximately 37k miles on Vehicle has issue based on climate temperature sensor triggers a computer code 84 vehicle goes into limp mode to prevent engine failure however, this happens instantly no time to react and more than one occasion creating a hazardous driving situation in heavy traffic, vehicle also overheats creating hazardous leaks of anti freeze at boiling temperatures ability to burn anyone who comes in contact. This remains an ongoing issue with vehicle, vehicle now back in possesion of bank Santander Consumer USA, this is being reported to protect any innocent parties involved to avoid injuries or even fatality