-
Service Brakes
11/30/2018
MY ABS LIGHT COMES ON WHILE DRIVING. AND WHEN I TURN MY TRUCK OFF. THIS HAPPENS ABOUT 3 OR 4 TIMES A DAY
-
Engine
10/10/2017
ON THE EXHAUST MANIFOLD, THE BOLTS BREAK OFF AT THE HEAD OF THE BOLT WHETHER THE VEHICLE IS IN MOTION OR NOT. SOMETIMES THE BOLTS BREAK OFF FLUSH WITH THE MANIFOLD AND SOMETIMES THEY BREAK OFF FLUSH WITH THE HEAD. I PERSONALLY HAVE HAD 6 OUT OF THE 12 BOLTS ON MY ENGINE BREAK OFF. THE FIX IS TO DRILL OUT THE REMAINING PIECE OF BOLT (THREADED PART) AND THEN USE A BOLT EXTRACTOR TO REMOVE THE REMAINING PIECE OF BOLT THAT IS STILL SEIZED IN THE HEAD. WELL, THE MOST COMMON BOLT TO BREAK OFF OUT OF THE 12 MANIFOLD BOLTS IS THE ONE DIRECTLY IN FRONT OF THE DRIVERS POSITION. UNFORTUNATELY, THAT IS THE HARDEST BOLT TO REMOVE BECAUSE OF IT'S LOCATION. MOST SHOPS I'VE BEEN TO SAY THAT THE TICKING SOUND THAT YOU HEAR ONCE THIS BOLT BREAKS OFF IS A LOOSE LIFTER. THAT IS INCORRECT! THE TICKING SOUND IS ACTUALLY AN EXHAUST LEAK STEMMING FROM, MOST LIKELY, THE BROKEN BOLT DIRECTLY IN FRONT OF THE DRIVER. THE SOUND GOES AWAY ONCE THE ENGINE WARMS UP BECAUSE OF THE METAL EXPANDING WITH THE TEMPERA...
-
Air Bags
11/06/2018
TL* THE CONTACT OWNED A 2000 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 80 MPH, THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF A SEMI TRUCK. BOTH THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED. THE CONTACT INDICATED THAT THE FRONT PASSENGER SIDE AIR BAG DEPLOYED ALTHOUGH IT WAS DEACTIVATED VIA THE AIR BAG DEACTIVATION SWITCH LOCATED ON THE LOWER MIDDLE SECTION OF THE DASHBOARD. NO INJURIES WERE REPORTED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
-
Service Brakes
10/16/2018
BRAKE LINE BURST BELOW DRIVER'S DOOR. WAS ABLE TO STOP WITHOUT CRASHING AS I WAS ONLY MOVING A FEW MILES PER HOUR IN A DRIVEWAY, THOUGH THERE WAS VERY LITTLE BRAKING CAPACITY. I SEE IN A SEARCH THAT THIS IS A VERY COMMON PROBLEM WITH SEVERAL YEARS OF GM TRUCKS. GM APPARENTLY ADMITTED THEY USED INFERIOR STEEL FOR BRAKE LINES. THIS IS OBVIOUSLY A SERIOUS SAFETY HAZARD.
-
Service Brakes
08/04/2018
BRAKE LINE UNDER THE CAB BROKE DUE TO RUST. I LIVE IN EAST TENNESSEE IN AN AREA THAT DOES NOT USE EXCESSIVE AMOUNTS OF SALT ON THE ROADS IN THE WINTER AND ALWAYS TAKE VERY GOOD CARE OF MY VEHICLES. I WOULD NOT EXPECT THIS MUCH RUST ON A SAFETY COMPONENT SUCH AS THE BRAKE LINE. WHEN SLOWING TO TURN OFF THE STREET INTO MY DRIVEWAY THE BRAKE PEDAL WENT NEARLY TO THE FLOOR AND THE BRAKES WERE VERY WEAK. THERE WAS NO ACCIDENT CAUSED BY THE LINE RUPTURE. I CALLED THE LOCAL GM DEALERSHIP AND WAS QUOTED IN EXCESS OF $1,000 FOR REPAIR.
