2025 Chevrolet Colorado Complaints

The headlights flicker/pulse creating visibility issues at night. This occurs when the heated seats are activated. This is a safety concern for myself, passengers, other drivers, and pedestrians. Flickering lights can cause an accident due to poor visibility and the creating of false shadows. This would also hinder the ability to see pedestrians. The problem was reproduced at the local Chevrolet dealer, they said they would contact Chevrolet, at my insisting. Initially they told me I should replace the stock halogen light bulbs with aftermarket LED bulbs at my cost. They said it is extremely unlikely that GM will do anything to rectify the issue because from the design standpoint of the vehicle everything is operating within its standards on paper. The manufacturer has initiated a case. There are no warning lights of any kind. This is a 2025 with 2,300 miles.

After the vehicle was parked and powered off for several hours, I started the truck and experienced an extreme and unexpected audio volume spike from the factory BOSE sound system. The startup sound and turn-signal chime played at an excessively loud level, far beyond normal operation. The sound was sudden and intense, causing immediate ear pain, ringing, and a headache. My dog, who was in the vehicle, became visibly distressed and shaken by the noise. This volume spike occurred before any media audio was playing and appears tied to the vehicle's startup and chime audio system, not user-adjustable radio volume. The turn-signal clicking remained extremely loud afterward, indicating the same audio channel was affected. The vehicle has been operating normally prior to this incident and had not been modified in any way. This occurred during normal use of a brand-new vehicle (purchased about a month ago) with no warning lamps/messages/ or other symptoms prior to the incident. The p...

I was driving down a hill and hit my brakes and the pushed back against me and then went right to the floor with minimal braking. I got an error message on my dash that said “brake system failure- do not exceed 62 mph” Luckily it was early in the morning and nobody was in front of me. All of the lights were green and between the engine braking and the little brake power that I had I made it up the hill (about a mile) to the Chevy dealership. I got an error notification the day prior that said there was an electrical error and my check engine light came in. I drove straight to the dealership but they couldn’t do anything since it was 4:30 and later than work hours so they made me an appointment for the next day and let me go. They told me later that day that it was an issue with the master cylinder (which with some research I found that there is an active lawsuit against this issue) I was issued a loaner vehicle with a crack straight across the entire windshield (it was all they ha...

My 2025 Chevrolet Colorado continues to experience roof denting caused by the vehicle’s structural weakness in the roof panel when exposed to normal car-wash air dryers. This problem began in 2023 with my previous model year Colorado, and it has carried into the 2025 model despite GM having issued an internal service advisory in 2023 describing the need to install additional roof braces to prevent this exact failure. GM acknowledged the issue two years ago but did not incorporate the recommended reinforcement into manufacturing. As a result, even routine exposure to the forced air from automated car-wash dryers causes the roof to bend inward. I have had this inspected multiple times, and the root cause has been consistently identified as inadequate roof support. The problem has not been corrected at the design or production level, and dealerships are not taking further action. The roof denting raises concerns about structural rigidity, potential weakening over time, and whether the r...

On the day of purchase, while driving on a freeway, the vehicle would not accelerate. The RPM's went up, the engine revved, but the vehicle acted as if it was in neutral. These vehicles will not accelerate if they think the brake pedal is also being pressed. The brake was not being depressed. As I was pulling the vehicle to the side of the road, suddenly it allowed me to accelerate again, and I continued with no further issues. One week later, with fewer than 200 miles on the vehicle, upon starting the dashboard showed alerts to Service ESC, Service Brake Assist, Service Trailer Brake System. The ABS and Traction Control lights also came on. These are all systems designed to prevent loss of control, and all failed without warning. A dealer service center diagnosed this as a known problem with a faulty master cylinder, on several models built over a period of several months.