2020 Chevrolet Bolt EV Complaints

GM installed Advanced Monitoring Software on the car rather than replace the battery. The software detected a battery fault. Under the battery recall if a fault is detected the battery is replaced free of charge. GM is refusing to replace the battery. Now the car will not move.

General Motors is using the arbitrary 6,213-mile tracking window of Recall 944 to deny coverage for a diagnosed Cell Section 3 hardware failure at 123,582 miles. However, this vehicle is directly impacted by the failure parameters outlined in the expanded GM Safety Recall N242470160 / N242470162, where GM openly acknowledges to federal regulators that the advanced diagnostic software has failed to properly detect defective battery modules. By denying a physical battery replacement when a manufacturing defect is caught during a mandatory corporate software reconfiguration, GM is violating the spirit and legal intent of their ongoing federal safety recall campaigns.

Steering stiffened over several weeks. Then steering wheel would not automatically return to center while turning while driving. Diagnosed by service as a fault with steering column. This is apparently very common in Chevy Bolts.

After putting washer fluid in, my son closed the hood. The hood did not latch. He tried again but it still didn’t latch. He lifted the hood to find the hood striker had come off the hood. There was nothing to hold the hood closed. I’ve included photos of the striker welds. There is no rust or tearing of the welds. It just separated. It was a bad weld.

When driving the car through a busy intersection there was a sudden, brief surge of acceleration, followed by deceleration and the vehicle cutting all motor power and becoming inoperable. The MIL lamp illuminated and the "Ready" light went out. I was unable to move the vehicle out of traffic until I got out and disconnected / reconnected the 12v battery to reset the car systems. The problem is difficult to reproduce, happening randomly, sometimes with multiple months between incidents. The incidents happen with no warning, and there are no other symptoms associated with the issue. The dealer mechanic indicated it is likely the issue indicated in Chevrolet TSB 19-NA-220, indicating the root cause is the resolver feedback connector on the electric drive unit damaged during vehicle assembly.