2022 Chevrolet Bolt EUV Complaints

The front facing camera and the rear backup camera and the entire camera system is intermittent. Sometimes it works and sometimes it does not. You become a bit dependent on the backup camera and when it does not work & it causes undue stress especially if you are handicapped in the neck turning area. The problem has not been taken to a dealer yet because they cost is prohibitive to just drive it in the door. When the failure occurs, there is a red triangle and a camera with a red circle with a red line through it. This is a documented problem (TSB 23-NA-062) with this model vehicle and should be made a recall. Many others have reported this same issue. Chevrolet will not fix it without cost of up to $1500 or more if the car is out of the 36K warranty

STEERING NOT RETURN TO CENTER. DEALER DIAGNOSED STEERING GEAR NEEDING REPLACEMENT. DANGEROUS ON TURNING ON A CORNER AS HAVE TO PULL WHEEL BACK TO CENTER MANUALLY.

There's a very common issue with these vehicles where the steering rack breaks and causes a number of issues including a clunking noise when driving over bumps and a rattle in steering wheel when turning left and right. However the most important and dangerous issue is that the steering wheel stops returning to center after making a turn. The steering wheel will move about 1/2 of the way back to center and then just stop and I have to manually turn it the rest of the way. You can imagine how dangerous this could be if someone doesn't realize what's happening and the car continues turning and goes into oncoming traffic. I have to manually turn the steering wheel back to center to avoid the car veering into the oncoming lane of traffic after making a turn. GM can fix it by replacing the rack, but it's a $4k repair and will happen again after replacing it.

The contact owns a 2022 Chevrolet Bolt EUV. The contact stated that while driving at an undisclosed speed, the electrical system became inoperable. The contact stated that the seat belt warning chime failed to function when the seat belt was not fastened. Additionally, the instrument panel became inoperable while attempting to reverse, and the rearview camera failed to function properly. The vehicle was taken to an independent mechanic, but was not diagnosed or repaired. The vehicle was then taken to the dealer, where it was diagnosed, and it was determined that the radio system and instrument panel screen had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 50,000.

Steering has been become stiff at lower speeds and does not return to center. There is also a knocking noise when making turns. Chevrolet dealer has indicated that the steering rack/gear needs to be replaced. Vehicle is at 115,000 miles, and the problem started happening around 112,000 miles. Although the vehicle does have a lot of miles, I've owned vehicles way past 200,000 miles and have never had to replace a steering rack at a cost of over $3,000.