-
Fuel/propulsion System
11/07/2018
THIS WAS A CONSUMER CALL RECEIVED BY REGIONAL OFFICE STAFF, AND IS BEING RELAYED. VEHICLE HAS AN ACTIVE FUEL SYSTEM RECALL, AND DEALER IN SALT LAKE CITY, UT SCHEDULED REPAIR, BUT CANCELLED THE REPAIR APPOINTMENT DUE TO NOT HAVING PROPER BILLING CODE TO BE REIMBURSED FOR THE REPAIR BY THE MANUFACTURER. PLEASE CONTACT CONSUMER DIRECTLY FOR FURTHER DETAILS AND TO ASSIST HIM IN RESOLVING THIS ISSUE.
-
Fuel System, Gasoline, vehicle Speed Control
10/01/2007
I OWN TWO OF THE ORIGINAL AUDI S4'S, BOTH 1993 MODELS. MY DAUGHTER WAS DRIVING ONE OF THESE CARS IN 2007 AND THE THROTTLE STUCK OPEN SO THAT THE ENGINE RACED UNCONTROLLABLY. SHE WAS ABLE TO PUT THE CLUTCH IN AND STOP THE CAR AND TURN THE ENGINE OFF. THEN SHE HAD THE CAR TOWED TO THE NEAREST REPAIR SHOP. IT WAS DISCOVERED THAT A PLASTIC PART ON THE TIP OF THE THROTTLE CAM HAD BROKEN OFF AND AS A RESULT THE THROTTLE CABLING MECHANISM STUCK IN THE PARTIALLY "OPEN" POSITION. I HAD THE THROTTLE CAM REPLACED WITH AN ALL STAINLESS STEEL CAM WHICH CANNOT BREAK DOWN AS A RESULT OF HEAT, AS PLASTIC OR A SIMILAR PRODUCT CAN DO. I HAD OEM CAMS REPLACED IN BOTH S4'S. AUDI DEALER WAS NOTIFIED OF THE PROBLEM IN OCTOBER 2007. I HAVE RECOMMENDED TO AUDI THAT ALL 1992-1997 S4 AND S6 MODELS BE RECALLED AND THAT ALL THROTTLE CAMS BE REPLACED WITH AN ALL STAINLESS STEEL CAM (FOR EXAMPLE, ONE FABRICATED BY 034 MOTORSPORT IN FREMONT, CA.) AT LEAST ONE OTHER INSTANCE OF UNINTENDED ACCELERATION, DUE...
-
Fuel System, Gasoline
04/08/2010
I RUN A SMALL REPAIR SHOP AND HAVE SEEN A NUMBER OF AUDI VEHICLES FROM 1986 TO 1998 WHICH HAVE STEEL GASOLINE LINES THAT COLLECT ROAD SALT AND RUST IN THE RUBBER SUPPORT GROMMETS ATTACHED TO THE CHASSIS. THE RUST CAUSES A PINHOLE LEAK WHICH THEN BEGINS TO SPRAY GASOLINE ON THE EXHAUST SYSTEM. I HAVE SEEN 5 OR 6 VEHICLES LIKE THIS IN THE PAST 5 YEARS AND SAW ANOTHER ONE LAST WEEK. *TR
-
Vehicle Speed Control
08/25/2005
PLASTIC THROTTLE CABLE PIECE BROKE RESULTING IN STUCK THROTTLE CONDITION. FOR AN ACCOUNT OF THE INCIDENT ALONG WITH PHOTOS SEE THE URL BELOW. *NM HTTP://WWW.S-CARS.ORG/POSTNUKE/MODULES.PHP?OP=MODLOAD&NAME=NEWS&FILE=ARTICLE&SID=183
-
Fuel System, Gasoline
02/10/2002
I HAD PREVIOUSLY CONTACTED NHSTA REGARDING FUEL LINE LEAKS IN THE ENGINE COMPARTMENT OF THE EALRY S4 AND S6 MODELS. THIS RESULTED IN THE "KY" RECALL CAMPAIGN. MORE RECENTLY, SOME OWNERS HAVE BEEN DISCOVERING LEAKS IN THE FUEL LINES GOING FROM THE REAR OF THE CAR TO THE FRONT. THESE LEAKS OCCUR AT THE POINT WHERE THE FUEL LINE GOES THROUGH RUBBER ISOLATION/MOUNTING BLOCKS. MOISTURE ACCUMULATES AT THESE POINTS AND CORRODES THE FUEL LINE RESULTING IN LEAKS. I DISCOVERED THIS ON MY OWN CAR IN EARLY 2002 AND I KEEP HEARING FROM MORE AND MORE PEOPLE FINDING THE SAME THING. THESE CARS HAVE BEEN EXTREMELY GOOD IN OTHER AREAS BUT THE FUEL SYSTEM PLUMING LEAVES MUCH TO BE DESIRED. DT
