2008 Volvo XC90 Complaints

BOUGHT OUR 2008 VOLVO XC90 IN 2010. LAST SPRING WE NOTICED A VERY STRONG FUEL SMELL COMING FROM INSIDE AND OUT SIDE THE VEHICLE THAT BECAME STRONGER THE MORE WE DROVE IT AND FOR SOME TIME AFTER IT WAS PARKED. LOOKED IT UP ON U-TUBE, THE FUEL SENDING UNIT (FUEL PUMP) UNDER THE BACK SEAT LEAKS OVER TIME ESPECIALLY IN HOTTER CLIMATES. THERE WERE SEVERAL DIFFERENT COMPLAINTS ON LINE DUE TO THIS SAME ISSUE, CONCLUDING A DEFECTIVE PART ON THE FUEL PUMP THAT FORMS A CRACK ON TOP AND LEAKS FUEL WHEN VEHICLE IS IN USE.. CALLED VOLVO MAIN OFFICE, GAVE THEM THE VIN # AND THEY SAID "NO, NOT ANY LIST !!" SO WE TOOK IT TO THE NEAREST VOLVO DEALER IN LAS VEGAS, ALL MOST 2 HOURS AWAY. WE ALSO WANTED TO KNOW WHY THE CHECK ENGINE LIGHT WAS YELLOW. TURNS OUT THAT IT WAS THE FUEL PUMP AND THEY WOULD GLADLY REPLACE IT FOR $487.00 BUT WOULD NOT BE ABLE TO DO THE WORK UNTIL OUR NEXT VISIT-HAD TO ORDER THE NEW PUMP. THEY HAD US SIGN A WAIVER BEFORE WE LEFT BECAUSE THEY " RECOMMEND VEHICLE NOT BE DRIVEN DUE...

FAN CONTROL MODULE NOT FUNCTIONING PROPERLY. LOSS OF COOLING SYSTEM FUNCTION AND ENGINE OVERHEATS. AIR CONDITIONER DOESN'T WORK PROPERLY. MECHANIC HAS CONFIRMED IT IS THE FAN CONTROL MODULE THAT IS FAILING. SAME YEAR DIFFERENT VEHICLES HAVE SAME ISSUES IN CASE # NHTSA CAMPAIGN ID NUMBER: 09V218000 N/A

I WAS DRIVING DOWN THE HIGHWAY AND MY VEHICLE COMPLETELY SHUT DOWN AND THE STEERING LOCKED. I WAS ABLE TO PUT ON THE EMERGENCY SIGNALS AND THE BIG RIGS BEHIND ME BLEW THEIR HORNS. THEY WERE GETTING CLOSER TO ME BECAUSE I WAS DECELERATING AT A RATE THAT WOULD HAVE RESULTED IN A COLISSION. FORTUNATELY I WAS ABLE TO COAST INTO AN EMERGENCY LANE WHILE THEY WENT WHIPPING PAST ME. THE VOLVO SERVICE MANAGER STATED THAT HE HAD HEARD OF A SIMILAR SITUATION BEFORE. IN AN EMAIL TO ME HE STATED THAT "THE PRESSURE SENSOR WAS GIVING A FAULTS READING, OF EXCESSIVE FUEL PRESSURE. WHEN THE PEM SAW THE FAULTS READING, IT CUT THE FUEL TO THE ENGINE AS IT THOUGHT IT WAS WAY OVER PRESSURIZED." I FEEL VERY FORTUNATE THAT NOBODY WAS SEVERALLY INJURED OR KILLED.

I OWN A 2008 XC90 WITH ONLY 21000 MILES ON IT. WHILE DRIVING, WITH MY CHILD IN MY CAR, I RECEIVED A MESSAGE "REDUCED ENGINE PERFORMANCE" AND MY CAR STARTED SPUTTERING. I BARELY MADE IT HOME, GOING OVER A SMALL HILL WAS A STRUGGLE. MIND YOU, THIS HAPPENED AT NIGHT AND I WAS SCARED TO DEATH THAT I WAS GOING TO BE STRANDED ON THE SIDE OF THE ROAD WITH MY CHILD. I HAVE READ ON FORUMS THAT THIS HAS HAPPENED TO OTHER CUSTOMERS AND VOLVO CURRENTLY HAS A VOLUNTARY RECALL FOR ETM AT NO COST TO THE CONSUMER. WHEN I ENTERED MY VIN ON THE VOLVO SITE NOTHING CAME UP. THIS IS MY MODE OF TRANSPORTATION AND I AM TERRIFIED TO DRIVE IT UNTIL THIS GETS RESOLVED QUICKLY.

TL* THE CONTACT OWNS A 2008 VOLVO XC90. WHILE DRIVING APPROXIMATELY 35 MPH, THE BATTERY WARNING INDICATOR REMAINED ILLUMINATED. A FEW MOMENTS LATER, OTHER UNKNOWN WARNING INDICATORS BEGAN TO ILLUMINATE. THE VEHICLE WAS MANEUVERED TO A SAFE LOCATION. THE FRONT DRIVER AND PASSENGER SIDE POWER WINDOW SWITCHES FAILED TO OPERATE WHEN ACTIVATED. THE ENGINE WAS TURNED OFF AND FAILED TO RESTART. ROADSIDE ASSISTANCE INSPECTED THE VEHICLE AND JUMPSTARTED THE BATTERY. THE VEHICLE RESUMED NORMAL OPERATION. THE CONTACT MENTIONED THAT THE SRS WARNING INDICATOR ILLUMINATED FOR TWO YEARS AND CONTINUED. THE REAR PASSENGER DOOR AJAR MESSAGE DISPLAYED EVEN THOUGH THE DOORS WERE CLOSED IN A SECURED POSITION. IN ADDITION, THE CHILD LOCK FAULT MESSAGE ILLUMINATED. THE FAILURES RECURRED AND PERSISTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 116,580.