2012 Volvo XC60 Complaints

On October 12, 2022 while driving home from the Schar Cancer Center in Fairfax, my 2012 Volvo XC60 experienced an end of life event. My check engine light came on when I entered my neighborhood. The car began sputtering and the gas pedal was delayed and at times, unresponsive. I was able to make it to my house and made an appointment to service my Volvo. My Volvo was towed to GT Peace Automotive on November 6. The three-week delay was due to their backlog of work. They are a trusted repair service and have provided service to all my vehicles over the past four years. The attached document indicates their assessment. Highlights include that the Volvo was a fire hazard in its current condition, the ignition coils were melted, and the circuits are shorted. GT Peace provided an estimate of $3,500 for repairs as a starting point to fully replace the engine harness. Their evaluation concluded that, based on other findings, the cost would easily go north of $3,500, possibly to $5,500. Base...

A faulty radiator anti-tamper device caused loss of communication to the engine control computer. The check engine light turns on and “charging failure-service urgent” message pops up during driving. Which cause the drivers worry even panic. I talked to local dealer several times. I was told to change battery everytime. But my battery and alternator were both tested fine. The message could pop up right after full charged battery. There are many complains at Volvo forums. Volvo knows the issue, but they decided not to recall it. The check engine light and messages pops up on and off by itself. The DTC codes are normally U0286 and/or B1087. I am already changed one battery. The problem is still there. It could cause accident because the message pops up during driving on highway and cause unnecessary worry and panic.

"Failure Charging" warning advisory light came on the dashboard. This problem has been going on for the whole ten years I have owned this vehicle. I am the original owner of this Volvo and had some engine warning on the dashboard since the first month. I took vehicle in to the Culver City Volvo for 1000 miles check-up and annual oil change and check-up for 5 years under warranty and requested software update and reported the engine stalling during the first month. The "failure charging" or "engine check" or "dangerous" "immediate" repair needed signs came on sometimes and did not come on other time. When the "failure charging" sign comes on and the engine is turned off and restarted the warning would go away sometimes. I believe this is a Volvo vehicle computer software malfunction. I reported this problem to the dealer for 5 years during annual service appointments. This problem was not solved and I have lived with this, stupidly patient for 10 years. Today, problem light came on duri...

The front windshield was not properly sealed during manufacturing and is now leaking when it rains. Water drips down the inside of the windshield in front of the driver resulting in distraction and poor visibility. I also fear that in an accident the windshield would not perform as it should and would be a safety issue. I brought it to the Volvo dealer and they just said I had to have it replaced but they do not provide that service. I brought it to a windshield service center and the technician was able to push on the windshield with only his hand and confirm that it was not sealed and showed movement. They also mentioned that have seen this issue many times with these cars. There were no warnings other than the leak which started a few months ago.

Lately my vehicle has been shutting off power when I hard right turn during parking everything shut off then I have to restart it again, but the scary part was what happened this morning I was driving on interstate and as I was charging lanes it almost powered off again but it picked up.