2023 Volkswagen Taos Complaints

My 2023 VW Taos Se has been diagnosed with head gasket failure. Denied “goodwill assistance.” I did state that VW has issued a TSB (TSB 15-23-01. I currently have 80,380 miles on the vehicle. Known engineering failure, not wear and tear.

Air bags did not deploy after a direct driver side hit, and I was injured because of the accident. Car was declared a total loss by the insurance. The car is being held by State Farm if inspection needs to happen. I was hurt because of the car accident, and I fear for my life or my child’s life if they would have been in the car. I want to prevent any future injuries. I was driving 50 MPH on route 60 when I was hit on my side. There was no warning light on prior to the failure.

In two separate instances the Autonomous Emergency Brake system was activated. Luckily there i didn't cause an accident. There was no one in front of me either times. Thats the worst of all the issues the vehicle has.

On April 27, 2025, in [XXX] , the vehicle displayed a low coolant warning in the morning. The owner replenished the coolant as instructed, the warning cleared, and the vehicle was driven to work without incident. Later that day, while traveling southbound on [XXX] at approximately 60 mph, the engine overheat warning activated, forcing the driver to stop and pull over. The vehicle required two separate tows — first to the residence, then to the dealership the following day. On April 30, 2025, the dealership completed a full warranty repair replacing the engine head gasket and seals under TSB 2071245/1, a Volkswagen-issued Technical Service Bulletin acknowledging a known manufacturing defect in the 2022–2023 Taos cooling system, for which there is no recall issued. A formal case was opened with VW Customer Care prior to the repair visit and is on record. This incident occurred just before the vehicle’s warranty expiration at 30,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF...

​SUMMARY OF SAFETY HAZARD: I am reporting a catastrophic and unpredictable loss of motive power in a 2023 Volkswagen Taos (4Motion with DQ381 DSG Transmission). The vehicle presents a critical electronic sensor failure within the transmission mechatronics unit that causes the vehicle to enter an immediate "Limp Mode" without warning. This has resulted in several near-miss incidents where the vehicle became immobilized in active traffic and on high-speed roadways. ​TECHNICAL DATA OF FAILURE: Factory-level ODIS diagnostic logs (recorded Feb 3 and March 17, 2026) reveal that the transmission’s "Actual position clutch 1" reports a constant value of -0.69 bar. In an automotive hydraulic system engineered for positive pressure, a reading of -0.69 bar is a physical impossibility (a vacuum state). This indicates a total failure of the pressure sensor/TCU logic, leading to the unintentional disengagement of the primary drive clutch. ​DECEPTIVE REPORTING RISK: Authorized service centers have bee...