2002 Volkswagen EuroVan Complaints

HEATED FRONT PASSENGER SEAT SMOLDERING. NO FIRE. MANUFACTURER WILL NOT CORRECT. OUT OF WARRANTY. PASSENGER SEAT HEATING ELEMENT PREVIOUSLY REPLACED UNDER EXTENDED VEHICLE WARRANTY. HEATING ELEMENT BURNED THROUGH CLOTH FABRIC. I BELIEVE THIS TO BE A MANUFACTURER DEFECT THAT DOES PRESENT A FIRE DANGER AND THERE SHOULD BE A RECALL. *TR

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN EUROVAN. BEFORE THE VEHICLE WAS DRIVEN OFF THE DEALER'S LOT, THE AIR CONDITIONING MOTOR FAILED. THE DEALER CHARGED $1,512 TO HAVE IT REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 56,965.

THIS CAR IS THE THIRD OF FOUR CARS, IN A TWO-DRIVER FAMILY. IT IS NOT DRIVEN FREQUENTLY. ONE DAY, WE NOTICED THAT THE CAR WOULD NOT RESPOND NORMALLY TO REVERSE GEAR: IT DID NOT LIKE ANY THROTTLE WHEN IN REVERSE, BUT SEEMED TO DRIVE O.K. WHEN IN DRIVE GEAR. THE NEXT TIME THAT WE DROVE IT, THE SAME THING HAPPENED, BUT THIS TIME, IT DID NOT RESPOND NORMALLY TO FORWARD DRIVE GEAR EITHER. I BACKED IT OUT OF MY DRIVEWAY SLOWLY, AND BEGAN TO DRIVE IT DOWN THE STREET. VERY QUICKLY I REALIZED THAT IT WAS NOT RESPONDING AND PARKED THE CAR ON THE STREET AND CALLED THE TOW-COMPANY TO HAVE IT TOWED TO THE DEALER. DEALER REPORTED THAT THE CAR HAD A BROKEN TRANSMISSION (ONLY 60,000 ORIGINAL MILES ON IT), AND THE REPAIR COST WAS $5700. WHILE THIS DID NOT CAUSE A SERIOUS ACCIDENT OR DEATH, IT DEFINITELY WOULD HAVE, HAD I IGNORED THE MATTER AND GOTTEN ON THE FREEWAY. I CONTACTED SEVERAL TRANSMISSION SHOPS AND THEY ALL SAID THAT THEY WILL NOT REPAIR THE TRANSMISSION BECAUSE IT WAS TOO COMPLICATE...

I WAS DRIVING MY 2002 VW EUROVAN OVER A CAUSEWAY GOING APPROXIMATELY 55 MPH. A WARNING LIGHT FLASHED SEVERAL TIMES THEN WENT OFF. I BELIEVE IT WAS A COOLANT LIGHT. THEN A STRANGE THUMP, THUMP, THUMP NOISE CAME FROM UNDER THE HOOD FOLLOWED BY SMOKE. SMELLED LIKE BURNING RUBBER AND SOUNDED LIKE A BELT BREAKING. I PULLED OFF AS SOON AS POSSIBLE (ANOTHER MINUTE OR 2) AND CAR DIED AS I COASTED OFF THE RAMP. I OPENED THE HOOD, BUT COULDN'T SEE PAST THE BLACK PLASTIC ENGINE COVER AND DIDN'T KNOW HOW TO REMOVE IT. AFTER SEVERAL PHONE CALLS, ABOUT 10 - 15 MINUTES LATER, SMOKE STARTED BILLOWING FROM UNDER HOOD. MY CHILDREN AND I DASHED AWAY FROM VEHICLE AND STOOD BY AND WATCHED IT BURN. CAR WAS IN GOOD REPAIR. I HAVE NO IDEA WHAT HAPPENED. BUT IT IS TOASTED LIKE A MARSHMALLOW. *TR

WE JUST EXPERIENCED A EXPENSIVE ($4500) PROBLEM WITH THE VOLKSWAGEN EUROVAN/WINNEBAGO RIALTA. ACTUALLY THE PROBLEM WAS RELATIVELY MINOR BUT BECAME MAJOR BECAUSE OF THE VW ENGINEERING. A SPROCKET THAT PART OF THE CAMSHAFT CHAIN DRIVE ASSEMBLY WAS WORN TO THE POINT THAT IT WAS ALMOST COMPLETELY ROUNDED. THIS CAUSED THE TIMING CHAIN TO JUMP. THE WARRANTY IS 50,000 MILES. THE PROBLEM STARTED AT 52, 000 MILES. I HAD IT REPAIRED AT 55,000 MILES. A LITTLE RESEARCH ON THE WEB SHOWS IT TO BE A KNOWN PROBLEM. THE SPROCKET APPARENTLY WAS NOT PROPERLY HARDENED ON A FEW OF THE VR-6 ENGINES. THE ABNORMAL WEAR STARTED FROM THE DAY THE ENGINE WAS ASSEMBLED BUT TOOK 52,000 MILES TO SHOW-UP. A DESCRIPTION OF THE PROBLEM WITH PHOTOS CAN BE VIEWED ON MY WEB PAGE AT: HTTP://WWW.REESPHOTOS.COM/VW/VW.HTM *JB