2005 Toyota Tacoma Complaints

My 2005 Toyota Tacoma had a recall due to potential frame rusting. I brought my Truck to my local Toyota Dealership for the frame inspection as stated in the recall notice I received. The frame did not need to be replaced and at a later date the frame was sealed per Toyota's remedy. In March of 2022 I had an issue with my truck that required the gas tank to be removed. As it turned out there was major rust to the frame that was located behind the gas tank that was never sealed during the original remedy to the frame rusting issue. I contacted Toyota about the issue and was told that the extended warranty for the Issue had expired. I was told to contact the local dealership. In conversation with the dealership I was told there was nothing they can do. I feel that if this issue has happened to my truck, there must be other trucks on the road with the same issue that the owners have no Idea what is happening to their frames that may cause a safety issue should the frame completely f...

The driver side seat belt does not go up and down to adjust position. It is attached to the access door. By not being able to adjust it from going up and down, it makes it hard to strap it into place next to the seat. This may wear out the sides of the seat belt in time. I have not had a Toyota dealer look at it yet. Thanks.

Rusty Frame Issue Toyota Tacoma had a warranty enchantment program that expired in 01/31/2019 . I took the Tacoma July 18 2022 to the dealership for regular maintenance and they told me “THE TECH NOTICED 2 LARGES HOLES IN THE FRAME WHICH IS GOING TO COMPROMISE THE STRENGTH OF THE FRAME”. When I asked why they didn’t change the frame during the inspection back in 2015 if they knew it was going to be a problem. They refused to give a good answer. I took the Tacoma to the dealership back in 2015 for a frame inspection the nonprofessional inspector chose not change the frame. I contacted Toyota Motor Sales USA and basically was told they couldn’t do anything because the warranty enchantment program already expired. I understand that the warranty enchantment program has expired but I don’t understand how I have full responsibility when I did my part as the customer by taking my Tacoma during the time window of the warranty enchantment program. This is not safe for me, my family of the citiz...

The contact owns a 2005 Toyota Tacoma. The contact stated that while his vehicle was parked, he noticed that the subframe was extremely rusted. The contact noticed a 10-inch crack on the inside driver’s side rear of the vehicle. The vehicle was taken to the dealer dealer and the contact was informed that the subframe needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 170,000. Consumer stated rust is the worst near the catalytic converters. It is also bad just in front of the rear tires. It’s a manufacturer flaw where they designed the double wall to where water could get in but not get out and the frame rots from the inside out. This truck was garage kept.

The differential drive housing failed due to corrosion resulting in the differential oil leaking out at a significant rate and in loss of lubrication of the differential gears. The condition was detected before any significant loss of material condition or function but could have lead to a loss of vehicle control if the differential had failed. The local Toyota Dealer has not reviewed the condition as of yet. A review of several Tacoma internet forum sights finds similar corrosion failures described (oil leaking from differential housing). There is no monitoring/warning indicator for the oil level condition in the differential housing in this vehicle.