-
Electronic Stability Control (esc)
11/06/2015
TRACTION CONTROL CAME ON DURING NORMAL DRIVING
-
Engine
09/18/2015
WE HAVE A VEHICLE WITH A 2.4LITER/4 CYLINGER ENGINE THAT IS LOOSING OIL AT A RATE OF 1QRT PER 1000 MILES AND NOW THERE IS A COOLANT LEAK COMING FROM THE GASKET SEAL BETWEEN THE ENGINE BLOCK AND HEAD. THERE IS NO GUAGE THAT TELLS YOU HOW MUCH OIL IS MISSING UNTIL IT'S TOO LATE AND THE ENGINE STARTS TO OVER HEAT. BOTH THE OIL AND COOLANT IS LEAKING ON ROADS, PARKING LOTS AND DRIVEWAYS, WHAT WE HAVE FOUND IS THAT THE BOLTS THAT ARE NEAREST THE LEAK ARE STRIPPED, THEY EITHER STRIPPED IN ASSEMBLY OR FLAILED DO TO OVERHEATING OF THE BLOCK DO TO THE ENGINE BLOCK NOT HAVING SUFFICIENT COOLING BECAUSE OF A HEAVY FOAM PAD THAT RESTRICTS AIR FLOE AROUND THE ENGINE CAUSING THE HEAD TO FLEX AND LEAK AT THE GASKET SEAL BASED ON ONLINE COMPLAINTS THERE ARE HUNDREDS, IF NOT THOUSANDS OF OWNERS WITH THIS SAME PROBLEM. SEEMS THAT SOME OF THESE ENGINES ARE HAVING SUCCESS BY DRILLING, TAPPING AND INSERTING NEW COILS INTO THE ALUMINUM BLOCK, WHICH MAY OR MAY NOT BE A PERMANENT SOLUTION. IT SEEMS TH...
-
Tires
09/15/2015
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER EQUIPPED WITH MICHELIN LTX M/S2 TIRES, SIZE: P225/75/R16 (NA). WHILE DRIVING 55 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE REAR OF THE VEHICLE BEGAN TO SHAKE. UPON INSPECTION, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE TIRE BLEW OUT AND THE THREAD SEPARATED FROM THE BELT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 98,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.
-
Seats
08/11/2015
BEGAN DRIVING VEHICLE A WEEK AGO, USED TO BE MY WIFE'S VEHICLE. I NOTICED A SQUEAK IN THE DRIVER'S SEAT, AND NOTICED IT WIGGLED. I EXAMINED THE MOUNTING BOLTS, AND ALL 4 SEAT BOLTS WERE LOOSE, NOT EVEN FINGER TIGHT. THE ONLY SERVICE PERFORMED ANYWHERE NEAR THE SEAT WAS RECALL WORK ON THE FLOOR MAT RETAINING CLIP AND A SEAL IN THE BRAKE MASTER CYLINDER, BOTH RECALLS WERE DONE SIMULTANEOUSLY AT RUDY LUTHER TOYOTA, 8805 WAYZATA BLVD, GOLDEN VALLEY, MN 55426. RECALL WORK WAS DONE A COUPLE YEARS AGO. I TIGHTENED THE BOLTS WITH MY OWN TOOLS. PASSENGER SEAT BOLTS WERE TIGHT.
-
Structure, unknown Or Other, visibility/wiper
05/27/2015
GAS STATION DID NOT CLOSE HOOD COMPLETELY AND IT BLEW OPEN WHILE TRYING TO ENTER THE HIGHWAY AT JUST OVER 40 MILES PER HOUR.THE SECONDARY SAFETY CATCH DID NOT HOLD OR WORK ! THE HOOD BLEW OPEN AND SHATTERED THE WINDSHIELD AND BENT THE HOOD UP INTO THE ROOF.THE TOPS OF THE FENDERS NEAR THE HINGES WERE ALSO RIPPED UP.
