2022 Tesla Model S Complaints

2022 Tesla Model S Plaid purchased CPO from Tesla Florida Inc. Jacksonville on 8/29/2025 for $75,533.19. Multiple unresolved safety defects. (1) Trunk closure obstacle-detection failure 10/15/2025: key fob fell in gap between liftgate and roof; powered liftgate continued upward opening cycle and compressed fob against fixed roof glass until rear glass shattered. $4,100 repair. Same cycle on a child hand or finger would cause crush injury or amputation. Tesla Model X tailgate and falcon doors have obstacle detection; Plaid liftgate lacks it. (2) Passenger-side rear door handle requires extreme pressure to operate, raised 10/25/2025; iced over 1/19/2026 compounding egress hazard. (3) Center console haptic backup gear selector non-functional plus observed main touchscreen reset/blackout events: no manual gear control during foreseeable touchscreen failure event. (4) HV battery umbrella valves and flood port plunger required replacement 10/25/2025. (5) Rear spoiler bilaterally detached as...

My 2022 Tesla Model S is equipped with 21" Arachnid cast alloy wheels. The wheel on the front driver side developed a structural crack under normal driving conditions with no road hazard impact or unusual driving events. The crack has caused a significant air leak, with tire pressure dropping from 44 PSI to 34 PSI over approximately 10 miles of normal driving. At 34 PSI on a 265/35ZR21 low-profile tire, there is meaningful risk of rim-to-road contact. The vehicle shakes noticeably during normal driving as a direct result of the pressure loss. The tires have approximately 13,000 miles on them. We are aware of multiple other Tesla Model S Arachnid wheel owners reporting identical cracking under normal use on [XXX] , suggesting a pattern consistent with a manufacturing defect in the cast alloy wheel design. This is a safety concern as the leak rate is significant and the condition could deteriorate without warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5...

The center high-mounted stop lamp (CHMSL / third brake light) fails on 2021 and newer Tesla Model S vehicles (including Plaid). This is a common issue reported by many owners, particularly as vehicles exit the warranty period. No redesigned or corrected replacement part has been made available by Tesla. Pre-2021 CHMSL units are incompatible and will not fit. Repair requires removal and replacement of the entire rear liftgate glass assembly, which is extremely expensive and labor-intensive for owners. Prior model years did not experience this problem. A non-functional CHMSL reduces the vehicle's visibility to following traffic and increases the risk of rear-end collisions, especially at night or in poor weather. This appears to be a design or manufacturing defect affecting safety. Discussions [XXX] Repair process [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle developed a leak in the AC condensate drain. The leak is directly above the safety restraint control module. The module got wet deactivating the vehicle and causing havoc with the airbag system. Many electrical systems turned off such as the power to the steering wheel buttons( the left blinker, the right blinker, and the horn). Luckily this happened while my vehicle was parked but if this happened while someone was accelerating or driving on the highway they would lose control of the vehicle. I spoke to a Tesla Service Tech about the concern and he informed me that this AC leak happens very often in the 2021 and newer Tesla Model S vehicles and that Tesla is aware that the AC drain leaks onto the Restraint Contol Module but has not created a technical service bulletin or a recall for the safety issue.

Complaint Category: Tires / Suspension Summary of Issue: I am reporting a recurring and deceptive safety defect involving extreme inner-edge tire wear on my Tesla Model S. On three separate occasions, my rear tires have worn down to the metal structural cords exclusively on the innermost shoulder, while the remaining 90% of the tread appeared in excellent, near-new condition. Safety Hazard: This defect creates a high risk of catastrophic blowout at highway speeds. Because the wear is hidden on the far interior edge of the tire, it is invisible to the driver during standard daily visual inspections. The vehicle’s non-adjustable rear suspension geometry (aggressive negative camber) places extreme stress on the inner shoulder, causing it to fail structurally while the rest of the tire looks safe. Tesla’s Response: Tesla Service has been unable to provide a permanent remedy, stating the vehicle is "within spec," despite the recurring nature of the failure. I am filing this to urge the NHTS...