2013 Tesla Model S Complaints

Front impact bumper separated from mount on one side due to rust. Noticed a noise from front of car when going over small bumps in the road. If we had been in an accident, the impact bumper would not have provided adequate protection for the passengers or vehicle components near the drivers front where the mount had separated from the bar. No other inspections have occurred. Pictures and info can also be found here: [XXX] Issue found during replacement of upper control arms. (image has an upper control arm that was removed from the same car at the same time with little/no rust) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Complete engine failure. Car became disabled and unable to move. Upon investigation, this was drive unit failure due to coolant leaking past the seal. A common issue of Tesla Model S and X with the large drive unit. I believe that this is a design flaw and should be a class action type situation. Can you help?

Driver's side rear control arm failure. The outside knuckle of the control arm cracked and is missing a portion. Tesla agrees this is SB-19-31-001 and will not repair without payment, due to the age of the vehicle. Vehicle has been serviced by Tesla multiple times without comment that this should be replaced.

The contact owns a 2013 Tesla Model S. The contact stated that while driving 30 MPH and depressing the accelerator pedal, the vehicle failed to respond as needed. The contact stated that the message "Take to Service" was displayed. The local dealer was contacted, and the vehicle was towed to the dealer by Tesla Insurance to be diagnosed. The contact was informed that the drive unit was rusted and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure via email and a letter. The approximate failure mileage was 150,000.

When driving my vehicle the rear axle snapped causing the vehicle to fishtail. When checked by insurance company for repairs they found the Air suspension and rear axle snapped. It took out the air ride suspension, and bent 2 rims. It caused damage to the front fender as well as both interior wheel wells on the driver's side. Due to the suspension issue it caused a rock to come up and cracked windshield. The issue caused my vehicle to leave the road as I could not control the vehicle.