2020 Subaru Crosstrek Complaints

The rear differential on my PHEV Crosstrek failed around 31,500 miles. My spouse was driving under 30mph and turning, and heard a clunking/popping/metal-on-metal sound that persisted intermittently for the remainder of the drive home. Since then on 1/8/26, the sound has been aggravated and persistent, every 45 seconds or so while driving, mostly while turning, so we brought it in and were alerted to significant and large metal shavings in the rear differential oil. The current service bulletin (03-95-24) the dealership is relying on to inform the replacement describes sounds much subtler than the sounds my car is making and I remain concerned about other components in my vehicle that may be impacted by this failure. This kind of failure is a safety risk and did occur in traffic in my spouse’s case. The metal-on-metal sounds and drivetrain resistance are alarming. Thankfully my spouse was able to safely get home and alert me to the situation so we could take it in. I have not engaged in...

At Miami Airport, with ample space behind the vehicle in front, a pickup truck with a very long sloping ramp trailer to carry several cars pulled into the stated space. The lefthand side rear of the trailer being well below my line of vision hit my bumper on the passenger side. My insurance provided GPS confirmed I was driving at 16 mph at the time. We both stopped. We looked at no damage to the trailer and seemingly minor damage to the car. We both drove off. I was about 500 yards from where I parked at the airport. After my return from the UK 5 days later I drove home and used the car for several days. At the time of the collision, my diagonal part of the seatbelt failed to restrain me. My chest hit the steering wheel and I have since experienced continuous pain. (No broken bones). The incident was a sort of sideswipe. Despite its roadworthiness, the car became a write-off as a support for the engine was found to be unexpectedly bent as well. Driving conditions were ideal....

The bolt attaching the front left corner of the seat to the rails came loose and allows the seat to wobble and bounce.

The rear differential on my Subaru Crosstrek Hybrid has failed twice. The first failure occurred around 12,000 miles and the second around 50,000 miles, both while maneuvering slowly in a parking lot. There were no warning lights or messages beforehand. The failure caused grinding and drivetrain resistance while turning. During the second incident, a certified Subaru dealer confirmed the rear differential had failed again. They also discovered that Subaru had issued a revised version of the differential that is no longer compatible with the original axles, requiring additional parts to complete the repair. I was informed the original design has been discontinued, suggesting Subaru was aware of an issue. This kind of drivetrain failure is a significant safety risk, especially if it were to occur at higher speeds or in traffic. The issue has now occurred twice on my vehicle under normal driving conditions, and was verified both times by a 2 Subaru dealerships in Southern California. W...

The 2019-2021 Crosstrek Hybrid has an issue with the fuel tank design. Subaru has finally released a TSB (Reference: 09-82-23R) that explains the issue in more detail and how the defective parts need to be replaced. In short, the fuel tank has a design flaw such that regular fuel corrodes the fuel tank and causes clogging in the vapor vent tubes. Subaru says it's related to fuel with high ethanol content, however I have been filling up with regular fuel and have still experienced the issue. I have personally owned two of these vehicles and experienced the occasional P0452 check engine light which when diagnosed by a licensed shop pointed to this fuel evap system issue. Subaru has finally acknowledged that this is a known issue and issued the TSB, however they have not yet issued a recall. The repairs for this issue are expensive and the symptoms are an occasional check engine light. I am concerned because this issue is not easily detectable and is expensive to repair. Since this involv...