2021 Lincoln Aviator Complaints

The driver-side front window regulator failed and was replaced on October 4, 2025. The passenger-side window regulator also failed and was removed and replaced on November 21, 2025. At the time each incident, the window would not raise using the car controls and remained stuck in the down position. Two window regulator failures on opposite sides of this vehicle just seven weeks and within roughly 2,400 miles apart does not indicate typical wear. It reflects a pattern failure consistent with a component defect. At the time of the October incident, I was actively driving the vehicle and the November incident when was while the car was parked, when the window failed and would not raise. After parking and then restarting my vehicle, the window remained fully or partially down and could not be returned to a closed and secured position. This created multiple safety and security risks, including: • Inability to secure the vehicle against theft or intrusion • Exposure to weather, rain, or deb...

1.) Exhaust System Failure (Flex Pipe / Catalytic Converter) The vehicle’s exhaust system—specifically the flex pipe connected to the catalytic converter—cracked and malfunctioned. This component is available for inspection upon request. As a result of the failure, exhaust fumes entered the cabin, creating a significant safety risk due to potential exposure to carbon monoxide. Prior to the failure, I noticed a persistent rattling noise at low speeds and while the vehicle was idling. The issue was inspected and confirmed by the dealership; however, I was informed that the repair falls outside of warranty coverage. I would like to know if this falls under safety hazard for emissions. 2.) Sunroof Glass Shattering Incident While driving, the sunroof glass suddenly shattered and appeared to implode outward. According to the dealership technicians, this may have been caused by thermal stress or frame-related tension. The glass is no longer intact but the remaining components and frame can b...

My vehicle’s camera system, including the backup camera, is experiencing an issue where the passenger-side camera fails to display properly, showing only a blank black area. I have reported this issue to my dealership for future inspection. It is not yet clear whether the problem persists during daylight hours; however, it poses a significant safety risk at night when visibility is already limited. The loss of the passenger-side camera view creates a blind spot that could increase the likelihood of an accident or injury.

For the first 39 months of my ownership my 2021 Lincoln Aviator Grand Touring plug-in electric hybrid would not charge properly and resulted in thousands of charge station fault alerts. The dealership was dismissive of the issue for years because it seemed to work for the few minutes when they charged it on their high voltage charger even though I voiced concerns about the charger port being bad on the vehicle and it not working properly at home. My Aviator would not charge unless the plug was in the exact perfect spot and rarely would make it to a full charge before faulting out. Eventually the port started making SPARKING NOISES, ELECTRIC FIRE SMELLS, and SMOKES when plugged in. I was afraid my Aviator was going to start a fire and burn my house down, so I stopped charging it for at least 6 months until a new service manager finally took the time to investigate the issue. It was found in May 2024 that not only was the charger cable that came with my Aviator when I bought it defe...

The "auto" mode on my Sync screen on my 2021 Lincoln Aviator does not always automatically switch between day and night based on ambient light levels. This is a blinding experience at night when the screen doesn't switch to night mode and the brightness is intense. This blinding screen makes it hard to see outside when it is dark which could lead to an accident. My dealer says I have the most up to date version of Sync for my vehicle and there is no fix for this problem.