2019 Hyundai Santa Fe Complaints

Vehicle: 2019 Hyundai Santa Fe, VIN [XXX] , exterior Quartz White Pearl. Component: Exterior factory paint (paint/trim). Complaint: This vehicle exhibits a systemic, progressive factory paint defect — excessive peeling and bubbling of the white finish that spreads from one body panel to the next. This is a known defect across this vehicle generation; Hyundai acknowledged it by issuing Warranty Extension Z05 (TSB 25-BD-004H), which extends paint coverage to 10 years/unlimited miles for affected white-paint vehicles including the 2019 Santa Fe. Hyundai repaired the hood under this warranty in 2025, during which the vehicle was out of service for 77 consecutive days. Since that repair, the defect has migrated to the adjacent fender and has also appeared on a door, demonstrating that it is spreading across the vehicle. Hyundai has offered to repaint only the single currently-visible panel rather than addressing the systemic defect. I am filing this complaint to document the defect and...

Hyundai recently had a service campaign that was issued to address an emissions related issue in CA. The service campaign was 9C2 and the TSB was 25-01-087H. After this software update was applied to my vehicle the engine is now sluggish on a cold start and the transmission is shifting differently at low speeds and low gears. It appears that the performance of my vehicle has been compromised. There is a Hyundai forum where many Santa Fe owners are experiencing the same issues after the software update. I have notified the service advisor at my local Hyundai dealership.

Engine is burning a tremendous amount of motor oil. Dealer does acknowledge engine is burning oil. No warning lights on. Told burning motor oil is normal for a hyundai engine. Engine can seize during driving with no warning and is a safety issue. Front struts are also failing. No warning and is a safety issue: Currently trying to get dealer to cover defective components under warranty. Nothing has been repaired or resolved as of yet.

Vehicle Information: 2019 Hyundai Santa Fe Mileage at failure: approximately 109,000 miles Manufacturer: Hyundai Motor Company The vehicle experienced a complete failure of the automatic transmission system. The failed component is available for inspection upon request. At approximately 98,000 miles, the vehicle’s check engine light illuminated. I brought the vehicle to an authorized Hyundai dealership for diagnosis while it was still within the 100,000-mile powertrain warranty period. The dealership inspected the vehicle and advised that no issue was found, and no repairs were performed at that time. Approximately 11,000 miles later, the vehicle experienced severe transmission problems, which progressed to complete transmission failure at approximately 109,000 miles. Safety Risk: The transmission failure resulted in a sudden loss of power and reduced vehicle operability while driving. This condition presents a potential safety risk to the driver and surrounding traffic, particularl...

Engine continuously burns oil excessively and the dealership is falsifying the oil consumption test. At my local oil change shop, there is no oil left on dipstick at 3,000 mile interval. When I took it to dealer for consumption test, they checked dipstick after 1,000 miles and it was OVER THE FULL LEVEL. How can the oil be over the full level? This indicates they overfilled it to begin with and invalidated the test. Hyundai corporate is doing everything they can do avoid addressing this issue with the 2.4 engine in these models. Additionally, the transmission already failed less than 70k miles on the car.