2016 Hyundai Santa Fe Complaints

Engine oil runs out quickly

The contact owns a 2016 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The vehicle was towed to the dealer, where the same diagnostic information was provided. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,322. The VIN was not available.

This is my 2nd engine on my 2016 Santa Fe Sport. My car has 190,000 miles and had a catastrophic engine failure, it’s been at the dealership for 2 months. Hyundai said my lifetime warranty on my engine is not covered cause I had a misfire in the #4 cylinder with less than 2,000 miles on the spark plugs. Hyundai warranty department only spoke to the dealership directly and had me speak to a case manager (which did nothing, they never even talked to the warranty department only the dealership) So in December I dropped my car off, it took over 2 weeks to take pictures and send them in to Hyundai warranty department, a week later Hyundai asked the dealership to further take the engine apart and get pictures of the rocker’s. The dealership is down to 2 technicians and said they will get to it when they can (remember I’m without a car and waiting for approval for my engine so they can get me in a rental car while my engine gets replaced). Over 3 week later the dealership finally sends the...

While driving down the highway at 65mph my 2016 Santafe Sport experienced engine failure. We sat on the side of the highway, next to an on ramp with high traffic beside a cement wall. When the tow truck arrived the driver was nearly ran over! There was no way to get the car to a safer location. After being towed to the dealership they said the engine failure would be submitted under warranty due to an issue with the connection rod bearing damage causing the engine to fail. It was denied because I was not the initial owner. A week later I received information about a class action suit against Hyundai for this very problem. As part of the suit they had extended the warranty. The dealership resubmitted my information and it was turned down again, this time for high mileage. Several months later the dealership wanted my car removed from their property, I asked them to submit it again. This time turned down because the KSDS was not updated prior to the engine failure. I now have a like new...

The contact's husband owns a 2016 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle failed to accelerate upon depression of the accelerator pedal. The check engine warning light appeared on the instrument panel during the failure. Despite the vehicle operating in LIMP Mode, the vehicle was taken to an independent mechanic where an oil change was performed. The mechanic warned after the service was performed that there may be an ongoing failure with the engine. Several days later, the contact stated that while in stop and go traffic, the vehicle stalled with the check engine warning light illuminated. Due to the failure, the vehicle was towed to an independent mechanic where a diagnostic test was performed; and the contact was informed that the failure might be related to the cam shaft. The contact had the vehicle towed to a dealer and informed that the failure was probably related to the high-pressure fuel pump. The high-pressure fuel pump was repla...