2008 Hyundai Santa Fe Complaints

Brought 2008 Hyundai Santa Fe to Carlsbad Hyundai dealership on 12/22/23 for Service Campaign 976, due to oil leaking from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. Dealership said the vehicle needed to be fixed but they needed to order parts and that it would take 2-3 wks. It has now been over 6 months. I have called the dealership and Hyundai America multiple times all to no avail.

In October 2021 the alternator failed due to an oil leak from the valve cover gasket. I paid the local Hyundai dealer to replace the alternator and they also said the battery was damaged because of the failed alternator so I paid for a new battery as well. The dealer never mentioned the recall on this vehicle for the leaking valve cover and did not disclose that the leak was known to cause alternator failure. I later learned of the recall and had the valve cover repair performed under the recall. However, Hyundai has refused to reimburse me for the alternator repair that I had already previously paid for, and likewise have refused to reimburse me for the battery. Clearly the problem was due to the known defect that resulted in the recall, so I am obviously entitled to compensation for the out if pocket repair expenses. Please advise me how to proceed.

My car has a recall, and the dealership is unable to fix it. There is also an issue with the oem control module that they are unable to get the part and unable to fix this because they do not have the correct software.

Reference Number: 11520065 This is a follow up to a previously submitted incident involving this same vehicle. My first submission was May, 2023, This vehicle experienced the exact same hazardous condition on February 26, 2024. on I-75 south. After driving on an interstate highway for about 1 hour, I noticed a traffic backup and proceeded to slow down as the traffic was nearly stopped. As I slowed my car down to nearly a complete stop, the engine suddenly surged forward with high rpm's as though the accelerator was pushed to the floor. I immediately pressed on the brake pedal as hard as I could to stop the car from surging forward and then quickly decided to put the transmission into neutral so I would not hit the car in front of me. The car eventually stopped surging and may have stalled. I finally got the car to move again by turning off the ignition and restarting it. I continued on my way and did not have a similar situation for the rest of my 30 minute highway trip. Like...

The contact owns a 2008 Hyundai Santa Fe. The contact stated that after a visual inspection of underneath the vehicle, he observed excessive corrosion on the subframe. The vehicle was taken to the dealer, who confirmed the excessive corrosion of the subframe. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 205,000.