2004 Honda Element Complaints

The trailer arm rusted at the mount. I was told it was not safe to drive. I have learned that this is a common problem with this vehicle and Honda has issued a recall in Canada, but not the USA. I also learned that there is a similar issue with I believe the Honda CRV and that has been in recall from Honda in I believe both Canada and the US. I found a place to do the repair and he said he has seen a lot worse than mine and has done many of these repairs.. The total repair cost is $1500. I also learned that due to its design water gets trapped in the mount and causes the rust, which sounds definitely like a design flaw. The repair entails fabrication a whole new mount for the trailer arm. I discovered it on June 7th when I was doing some under body clean up.

The rear left trailing arm mounting point is completely corroded through, making the car unsafe to drive. If it were to fall off during driving the chances of it creating an accident are high. There are many other Elements with this specific spot rusting through.

● The area of the body that serves as the forward mounting point for the rear driver-side trailing arm has completely rusted though. At this mounting point, the trailing arm mounting bracket has become entirely separated from the body leaving only one bolt securing the trailing arm to the body. This is the same issue for which these vehicles have been recalled in Canada. Yes, the vehicle is available for inspection upon request. ● Continuing to operate the vehicle in this condition presents the possibility of catastrophic failure of the trailing arm mount, resulting in loss of control of the vehicle, endangering the lives of those in and outside of the vehicle. ● No, I have not taken the vehicle to a dealer or service center. ● No the vehicle/component has not been inspected by the manufacturer, police, or insurance representative. ● No warning lamps, messages, or other symptoms prior to the appearance of the problem on [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO...

I'm am told the component that failed is the "lower control arm." The vehicle is available for inspection. At the onset of this problem was a loss of control of my steering. At first I felt a play in the steering wheel when I made a small adjustment in my turn and felt the car move more than what it would normally do. I thought it was the waves in the road due to frost heaves. Then within about 3/4s of a mile the left "lower control arm" separated from where it was being held and fell to the ground. I heard a dragging noise in the back left area of my vehicle and was fortunate to be in front of a parking lot and was able to immediately pull in out of traffic. The car was towed to our auto repair shop where I was told it was unfixable. I also called the Honda dealership and explained the issue, and was confirmed that the car is unfixable, and was told that presently the part causing this issue is being recalled in Canada, but not yet in the USA. I wanted you to know that this happen...

There is a corrosion recall on 2003-2014 Honda elements in Canada because, from salted roads, the frame rusts and extremely important safety parts can break and cause death to the driver. Seeing as these elements are made in the same factories and are in the same region (mine is in Detroit Michigan, only 10 minutes from Canada) this recall NEEDS to be extended to the USA or at least the regions where salted roads and snow are prevalent. My Honda element suffers from this exact problem but I can do nothing about it.