2015 Ford Transit Connect Complaints

2015 Ford transit connect 150: while driving on the freeway 60-65 mph, the brakes seem to lock up without depressing the pedal, slowing to 40 mph and shaking uncontrollably. putting on the brake to exit the flow of traffic, braking caused the vehicle to shake even more finally by pumping the accelerator, the speed increased again. finally getting off of the freeway the brake pedal went to the floor. i had to pump the brake pedal until it finally reacted. less than a week later, getting on the freeway almost the exact thing happened. luckily i was a bit more prepared when i felt the shaking. today, driving the van back to our warehouse approx 15 miles on regular streets (not freeway driving) the brakes again went to the floor. master cylinder not leaking, brakes seem to be in good shape...but something is wrong we brought the vehicle to Sawgrass Ford in Sunrise Florida. they had it for over a month. they were unable to determine the problem and only made suggestions to complete...

The vehicle receives a considerable amount of water through the windshield when it rains (it can be more than a liter depends of the time on the road) it runs down through the glass and also falls on the dash. It can cause visibility problems while driving because the water run on the the driver's side of the glass too.

Steering knuckle developed a crack through what appears to be defective casting of the part. Crack was noticed prior to separation of steering assembly. This could have created and extreme hazard if not noticed prior to total failure.

The fuse associated with the rearview camera of this vehicle has consistently blown over the last few years leaving the backup camera inoperable with no image on the dashboard display. The lack of a functioning backup camera results in the loss of a view directly behind the vehicle which could result in an accident. A warning stating that "rear view camera is unavailable" and a dark display occur when the fuse is blown. The rearview camera fuse blows often typically only after a few vehicle trips. After diagnosing the blown fuse issue, chafing of a wiring harness was found behind a grommet where wires pass between the vehicle body and the rear liftgate. The damaged wiring harness is in the vehicle and available for inspection. This issue has also been documented by others as was discovered by searching for information on the internet.

The steering rack is not moving freely. Struts, tie rods and U joint are moving freezing but the steering rack is not. This is a huge safety concern because if the steering rack were to lock up and then allow me, the driver, to turn the wheel, that would absolutely cause me to crash. My local automotive service has diagnosed the problem