1996 Ford Thunderbird Complaints

TIRE ON 2 CASES BLEW THE TREAD AND BELT, THE LATER OF THE TWO INCIDENCES WHICH RESULTED IN A CRASH THAT TOTALED THE VEHICLE, AND RESULTED IN TWO INJURIES TO BOTH THE DRIVER AND THE PASSENGER. BOTH NEEDED TO BE HOSPITALIZED.*AK

TL* - THE CONTACT WANTED TO HAVE REPAIR DONE TO 1996 FORD THUNDERBIRD, HOWEVER SERVICE BULLETIN #97M91, DATED JAN 19, 1998 (NHTSA ITEM NUMBER: 605621) EXPIRED AND FORD CHARGED FOR THE REPAIRS. THE MILEAGE AT THE TIME OF THE FAILURE WAS 80000. THE CONTACT SAID THAT THE SERVICE BULLETIN WAS FOR THE INTAKE MANIFOLD. THE CONTACT WROTE TO FORD. THE REFUSED TO HONOR THE SERVICE BULLETIN. *AK UPDATED 2/6/2007 - *NM

DEFECTIVE INTAKE MANIFOLD ON 1996 FORD THUNDERBIRD. THE CAR ONLY HAS 84,450 MILES ON IT! COST WAS $1002.02 TO REPAIR. WHY IS THE CONSUMER BEING CHARGED FOR THIS COSTLY REPAIR WHEN THIS IS A KNOWN DEFECTIVE PART FROM THE FORD MOTOR COMPANY?*JB

DT*: THE CONTACT STATED, WHILE TRAVELING AT 30 MPH THE BRAKES FAILED WHILE PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE VEHICLE WAS TOWED TO A SERVICE DEALER, WHERE A LEAK WAS FOUND ON THE DRIVER'S SIDE FRONT HYDRAULIC BRAKE LINE. THE LINE WAS CORRODED TWO INCHES FROM EITHER SIDE OF A CLIP HOLDING THE BRAKE LINE. NO OTHER CORROSION WAS FOUND ON THE REMAINING BRAKE LINES.

DT*: THE CONTACT STATED THAT THE SPEED CONTROL DEACTIVATION SWITCH WAS LEAKING FLUID. THERE IS A NHTSA RECALL ON OTHER FORD VEHICLES. THE VIN WAS NOT INCLUDED IN THE RECALL. WHEN THE VEHICLE WAS TAKEN TO A SERVICE DEALER, THE REPAIR WERE MADE FOR A FEE. ALSO EVERY 25000 MILES, THE OIL PAN GASKET NEEDED TO BE CHANGED DUE A SMALL LEAK. THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. THIRD, THE EXHAUST AND INTAKE MANIFOLDS WERE LEAKING CAUSING A NOXIOUS SMELL INSIDE THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO THE SAME SERVICE DEALER. THE DEALER REPLACED BOTH MANIFOLDS, AND DETERMINED THAT THERE WAS AN OIL LEAK DRIPPING ONTO THE EXHAUST SYSTEM.