2018 Ford Fusion Complaints

Coolant Intrusion issue with the 1.5-litre EcoBoost. Short block was replaced by Ford Dealer then engine failed again after only 7,000-miles. Required complete new engine installed at my expense, $12,185.28.

I own a 2018 Ford Fusion EcoBoost. I purchase it in 2021 with 11K miles on it.  Today it has 34K miles and the engine block developed a crack.  Through my research and my Ford dealer, I've discovered this issue is a known issue with the 1.5 and 2.5 litre engines in the Fusion.  My repair bill would be just about 7K. 

My engine failed months ago, and my car has been sitting immobile ever since. My car stuttered while driving, and then turned off. As I started it back up and continued driving down the road, it was shaking very badly. I called my brother to come drive my car home and he pulled clear fluid out of my oil tank. The exact issue described has been put out in the new ford recall under code 26S43.

Ford's double-capped acorn lug nuts experienced outer cap expansion/separation during an emergency roadside tire change. A defective design known by Ford. Rendering the supplied tire iron and a separately purchased multisize tire iron ineffective at removing the lugs. The failure left the vehicle immobile on the side of a i75 in SWFL in the summer heat of June 2026. Present in the vehicle were the owner, spouse, and a [XXX] infant. They were stranded approximately 34 miles from home for nearly 3 hours, an extended period for a XXX, who quickly became visibly distressed. Standard FDOT Road Ranger assistance was unavailable, and towing services had estimated wait times exceeding 2 hours. The driver was unable to resolve the situation through any reasonable self-help measure due to the defective lugs, despite having successfully changed tires on the same vehicle previously using the same factory equipment. The defect was verbally identified during the incident by a responding AAA roadside...

I purchase this car on XXX Clinton Ford Dealership and engine need replacement Jan 2020 . I at that time did many replacement until the final diagnostic said engine replacement confirm by dealership Ford Dealership Fayetteville NC . The purge valve canister went out in 2022 and was replaced by Ed’sTire in Hope Mills Rd 11/19–11/22/2022 and now mechanic said it is in need of replacement again . Car problems started 2026 Feb and three pieces were replaced because the system was reading those code now to find out the purge valve canister needs replacement again. These hardship have cost me financial difficulties that a new car should never have had within 2 years . I believe no consumer should have to go through this.