2003 Ford Excursion Complaints

TL* THE CONTACT OWNS A 2003 FORD EXCURSION. WHILE DRIVING 70 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY TO APPROXIMATELY 75-80 MPH. THE CONTACT HAD TO APPLY EXCESSIVE FORCE TO THE BRAKE PEDAL TO SLOW DOWN THE VEHICLE. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

TL* THE CONTACT OWNS A 2003 FORD EXCURSION. WHILE REVERSING THE VEHICLE, THE STEERING WHEEL FAILED TO OPERATE. THE CONTACT NOTICED THAT THE STEERING WHEEL BOLTS WERE FRACTURED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 235,000.

FAULTY EXHAUST MANIFOLD BOLTS BREAK OFF AND CAUSE EXCESSIVE NOISE, EXHAUST ENTERS THE DRIVERS CABIN, VEHICLE WILL NOT PASS EMISSIONS INSPECTION AND IS EXPENSIVE TO REPAIR. I HAVE 4 FORD VEHICLES WITH THIS PROBLEM. FIRST INCIDENT WAS AT AROUND 50,000 MILES AND 48 MONTHS AFTER PURCHASE. FORD REFUSED TO MAKE REPAIRS UNDER ANY PORTION OF THE FACTORY WARRANTY. THEY CLAIM LIFETIME EMISSIONS WARRANTY DOESN'T COVER IT, NOR THE 100,000 POWERTRAIN WARRANTY. I HAVE SPENT OVER $8000.00 MAKING REPAIRS TO THESE EXHAUST MANIFOLDS. TRITON V-10 GAS ENGINE.

THE 6.8 AND 5.4 ENGINES HAVE BEEN FAILING DUE TO DEFECTIVE VALVE TRAIN CAM FOLLOWERS. I AM HAVING THE 3RD ENGINE INSTALLED IN MY EXCURSION. THE CAM FOLLOWERS ARE FAILING AND SPITTING THEM OUT CAUSING CATSTROPIC ENGINE FAILURE. I HAVE BEEN IN CONTACT WITH ANTHONY BARIANA WHO WORKS FOR HOLMAN DISTRIBUTION IN NEW JERSEY @ 1-800-521-1223 EXT 305 AND HE CONFIRMED THAT THE 6.8 AND 5.4 ENGINES HAVE HAD THE SAME PROBLEM AS MY TRUCK AT AN ABNORMALLY HIGH RATE. MT TRUCK IS CURRENTLY AT MATTHEWS PAOLI FORD 610-644-4700 AND THE GENERAL MANAGER BRYAN LIPPINCOTT TOLD ME THAT THEY HAVE REPLACED 6 STATE FARM TRUCK ENGINES IN 2.00 MONTHS 6.8 LITER SAME AS MINE IDENTICAL PROBLEM. FORD HAS DONE NOTHING FROM WHAT I SEE DOING SOME RESEARCH BUT THIS IS AN ONGOING PROBLEM AND FORD HAS DONE NOTHING TO ADDRESS THE PROBLEM AND MADE NO ATTEMPT TO FIND THE ROOT CAUSE AND HAVE A FIX SO THIS WILL STOP COSTING CONSUMERS THOUSANDS OF DOLLARS. I WAS DRIVING ON MY STREET AND WITHOUT WARNING THE ENGINE STARTED TO SHAKE...

TAMARA RECALL WHILE DRIVING OR STOPPED THE CARS POWER DOES 100% SHUT OFF. NO CODES OR WARNING LIGHTS. IN DEC/2016 DRIVING ON A ON A EAST ON CHARLESTON BLVD IN NV, AFTER PULLING OUT OF CIT BANK PARKING LOT GOING ABOUT 45 MPH THE LIGHT TURNED RED AND WHEN I WENT TO BREAK THE PEDAL WAS HARD AND THAT'S WHEN I SAW NO POWER. BY THEN IT WAS TOO LATE AND WE WERE GOING TO CRASH. I HAD NO POWER STEERING OR ABS AND I HIT THE CAR. IT CAUSED 12000 OF DAMAGE TO THE CAR IN FRONT OF ME. NO AIRBAGS DEPLOYED. ONLY BUMPER AND FOG LIGHT DAMAGE TO MY TRUCK THANKFULLY. AFTER THAT THE PROBLEM DIDN'T RE ACCUR UNTIL 2/2017 AND LEFT ME STRANDED OVER NIGHT ON THE ROAD AND NOW LAST NIGHT 5/13/2017 THE CAR WAS OFF NO KEYS IN THE IGNITION AND I SAW SMOKE THAT CAME FROM WHERE THE BATTERY SITS NOT SURE WHAT THAT WAS BUT ODD IT WAS. IT HAS NO RHYTHMIC PATTERN, I HAVE REPLACED THE BATTERY FUSES RELAY AND FUEL PUMP, ALSO CHECKED CAM SHAFT AND CRANK SENSOR. IT HAS SPARK GAS AIR AND COMPRESSION. IT'S A VERY L...