2015 Chevrolet Volt Complaints

"SERVICE AIRBAG" WARNING ON 2015 VOLT, WHICH APPARENTLY IS A WELL-KNOWN ISSUE FOR WHICH GENERAL MOTORS REFUSES TO TAKE ANY RESPONSIBILITY. AIRBAGS SHOULD NOT BE A CONCERN ON CAR--EVER. THEY WANT OVER $800 FOR THE REPAIR WHEN IT IS CLEARLY A MANUFACTURING DEFECT.

THIS VEHICLE HAS 84,500 MILES ON IT AS OF JUNE 2020. I AM THE ORIGINAL OWNER. DURING A STATE MANDATED SAFETY INSPECTION IN JUNE 2020, BOTH OEM OUTBOARD REAR BRAKE SHOES WERE FOUND TO HAVE SEPARATED INTO 2 PIECES AND FAILED INSPECTION. THE SEMI-METALLIC BRAKE PAD HAD SEPARATED FROM ITS METAL BACKING PLATE. I BELIEVE THE TWO PARTS OF THE BRAKE PAD ASSEMBLY ARE HELD TOGETHER WITH AN ADHESIVE, AND THE ADHESIVE FAILED ON BOTH PADS IN SIMILAR FASHION. AN INTERNET SEARCH REVEALED THAT THIS BRAKE PAD SEPARATION HAS OCCURRED TO A NUMBER OF CHEVY VOLT VEHICLES. REGENERATIVE ELECTRIC BRAKING MEANS THAT THE HYDRAULIC BRAKES (AND THUS THE BRAKE PADS) ARE RARELY USED ON THIS VEHICLE. THE BRAKES HAD NEVER BEEN SERVICED ON THIS VEHICLE, SO THE PADS WERE OEM. I HAVE RETAINED THE BRAKE PADS FOR REVIEW OR ANALYSIS.

WHEN IT RAINS OR THE CAR GETS WET, THERE WILL BE WATER THAT RUNS DOWN FROM THE UPPER RIGHT CORNER OF THE PASSENGER SIDE INTO THE FLOORBOARD CAUSING THE CARPET TO GET SOAKING WET AS WELL AS THE ELECTRICAL COMPONENTS THAT RUN UNDERNEATH THE CARPET. IT APPEARS THE SEALANT UNDER THE HOOD AND UNDER THE COWL IS FAULTY CAUSING WATER TO LEAK INTO THE CAB. THIS OCCURS WHEN THE CAR IS STATIONARY OR IN MOTION. THIS IS A FACTORY DEFECT AND NEEDS TO BE CORRECTED, NOT TO MENTION THAT THE ELECTRICAL COMPONENTS GETTING WET COULD POTENTIAL CAUSE A FIRE OR HAZARDOUS SITUATION. ALSO I TOOK IT BY A CHEVY DEALERSHIP BUT THEY COULDN'T FIND ANYTHING IN THE ALLOTTED DIAGNOSTIC TIME WITHOUT HAVE TO CHARGE ME MORE TO REMOVE SEATS AND CARPET. I DECLINED.

WHILE DRIVING ON THE HIGHWAY THE INSTRUMENT CLUSTER WENT BLANK AND TURNED OFF. THIS HOUSES INFORMATION LIKE WARNINGS, SPEED, FUEL LEVEL, BATTERY LEVEL, TRACTION, NAVIGATION, ODOMETER, LIGHT SIGNALS AND OTHER INFORMATION. THIS IS A HUGE SAFETY ISSUE WHILE TRAVELING DOWN THE ROAD AND LOSING YOUR ABILITY TO LOOK AT THE SPEED OR IF YOUR BLINKERS OR LIGHTS ARE ON.

IF THE EXTERIOR THERMOSTAT DETECTS THE TEMPERATURE IS AT OR BELOW 37 DEGREES FAHRENHEIT, THE A/C COMPRESSOR WILL TURN OFF AND ALL OF THE WINDOWS (WINDSHIELD INCLUDED) WILL FOG UP. RESULTING IN EXTREMELY REDUCED VISIBILITY. IF THE EXTERIOR THERMOSTAT DETECTS THE TEMPERATURE OF 38 DEGREES FAHRENHEIT OR HIGHER, THE A/C COMPRESSOR WILL ENABLE AND THE WINDOWS WOULD IMMEDIATELY CLEAR.