2012 Chevrolet Volt Complaints

Coolant leaking and damage to Drive Motor Battery Coolant Radiator due to the design of the vehicle that allows for rocks and debris large enough to damage radiator through. There is a service bulletin (13-06-02-001A) for this issue. When the radiator is damaged, the driver will suddenly receive a check engine light, reduce propulsion notice, and engine not available message. The car will suddenly stall and this cause a major safety concern especially on highways at high speed. However no active recalls, even though this is a common reoccuring problem amongst first generation Volts.

Vehicle propolusion reduced and engine not available messages were suddenly showing. Check engine light turned on. Suddenly Stalled/stopped in the middle of highway. Safety concerns

In September 2019, the Office of Defects Investigation (ODI) opened [XXX] to assess the malfunction of the Passenger Sensing System (PSS) in the 2012-2013 Chevrolet Volt vehicles. Due to that malfunction, the air bag system malfunction indicator light is activated. This could cause the passenger airbag to be suppressed in a crash. In July 2021, the ODI closed [XXX] after GM instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. In July 2023, I took my 2012 Volt to a local dealer to correct this problem, only to learn that the necessary replacement part has been DISCONTINUED by GM and is no longer available. That is, frankly, unconscionable. I am requesting that ODI reopen the investigation and take further action to compel GM to make this repair available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This issue has been reported extensively: NHTSA PE19013. The passenger seat sensor has failed leading to the airbag turning on and off rapidly while driving. This is available for inspection upon request. I worry about the safety of occupants in the car. If the airbag is turned off despite a passenger sitting in the seat that is a problem. The price of repair at a dealer is very high considering that this is a very clear quality control issue by GM that has been acknowledged by both GM and NHTSA. This warning light has turned on before and then went away for a long time. Now it has returned and after some research it is clearly an issue that many other 2012-2013 volt owners have experienced.

The contact owns a 2012 Chevrolet Volt. The contact stated while operating the vehicle, the front passenger’s side air bag warning light remained illuminated. The vehicle was taken to the local dealer who determined that the front passenger’s side air bag Passenger Sensor System was faulty and needed to be replaced. The vehicle was not repaired. The contact was informed that the part to repair the vehicle had been discontinued and no repair was available. The manufacturer was contacted and confirmed that the part was discontinued. The failure mileage was 100,000.