2022 Chevrolet Malibu Complaints

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle suddenly decelerated and went into LIMP Mode. The contact continued driving until being able to safely stop. Once the vehicle was stopped, it was turned off and restarted after a while. The failure occurred while the contact was attempting to accelerate and had become more persistent. The check engine warning light was illuminated with the message “Reduce Engine Power” displayed. The vehicle was taken to the dealer, who diagnosed that there was a failure with the turbocharger. The vehicle was being repaired. The manufacturer was informed of the failure. The manufacturer informed the contact that there was no recall for the issue. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 128,000.

Component/System Failure: The turbocharger system failed, specifically the wastegate arm, resulting in loss of boost and reduced engine performance. The failed component should be available for inspection upon request through the servicing dealership. Safety Risk: The failure caused a sudden loss of engine power while driving, placing me and others at risk, especially in traffic situations where acceleration is required (such as merging, crossing intersections, or maintaining speed). This created a hazardous driving condition. Confirmation of Issue: The problem was diagnosed and confirmed by an authorized dealership. The diagnosis stated: “turbocharger wastegate arm damaged causing loss of boost and DTC,” which matches known issues described in GM’s Special Coverage. Inspection History: The vehicle has been inspected by the dealership service department. It has not yet been inspected directly by the manufacturer, police, or insurance representatives. Warning Signs Prior to Failure:...

The contact owns a 2022 Chevrolet Malibu. The contact stated that while her husband was driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with turbocharger failure. The dealer informed the contact that the vehicle was under recall. The vehicle was repaired; however, after the vehicle was serviced, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed and determined that the charger air cooler had failed and needed to be replaced. The contact was informed that the vehicle was not under recall. The vehicle was not repaired due to the cost. The vehicle was picked up and then taken to Auto Zone for a diagnostic test. The diagnostic test retrieved DTC: P0234 (Turbocharger/Supercharger "A" Over Boost Condition (Engine and Engine Cooling). The manufacturer was not made aware of the failure. The failure mileage was 77,157.

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving approximately 30 - 35 MPH, the vehicle unexpectedly stalled. There was no warning light illuminated. The vehicle was coasted to the side of the road, where they turned off the vehicle. There were no warning lights illuminated. A mobile mechanic was called and inspected the vehicle. The mechanic retrieved DTC: P023F (Fuel Pump - Secondary Circuit Failure). The vehicle was towed by a family member to the residence. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 42,000.

When shifting my car into park the vehicle did not recognize that the gear was indeed in park. I would get a message saying “Shift to Park” and I could not fully turn my car off. This problem made me feel unsafe as I didn’t know what to do when it wouldn’t turn off. My battery could have run down and I would be stranded. In researching this problem GM was sued for the very same problem in earlier models so I am incredulous that they have not fixed this issue or initiated a product recall. I had to have an internal switch replaced at a GM dealer service center at my expense and the car only had 15263 miles on it.