1997 Bmw 540i Complaints

1997 BMW 540I FUSE TO THE FUEL INJECTOR BLEW OUT.***NO ANSWER REQUIRED*** *MR THE VEHICLE WOULD ALL OF A SUDDEN DIE WHEN IN MOTION DUE TO THE BLOWN FUSE(S) TO THE INJECTOR. THE THERMOSTAT TEMPERATURE SENSOR HAD AN INTERNAL SHORT WHICH CAUSED THE WIRE TO MELT AND BLEW THE FUSE. THE SUNROOF WAS INOPERATIVE DUE TO THE RAIL LIFT PIECES BEING BROKEN. *SC THE WIPER BLADES WERE NOT CLEANING THE WINDOWS PROPERLY. *JB

THE RADIATOR NECK BROKE OFF WHILE DRIVING AT HIGHWAY SPEED ON MY 1997 540I. IT IS A COMMON PROBLEM WITH BMW BY ALL ACCOUNTS, OWNERS, TECHNICIANS AND EVEN MY OWN PREVIOUSLY EXPERIENCED IT WITH AN 1988 735I. PLASTIC PARTS ON THE RADIATOR IS UNACCEPTABLE, DANGEROUS AND COSTLY. THIS HAS BEEN A PROBLEM FOR MORE THAN 10 YEARS ON THESE EXPENSIVE LUXURY VEHICLES WITH NO RESOLUTION BY BMW.*AK

(1) REPLACED WATER PUMP AND ACCESSORY BELTS. ON A FORUM THAT I READ, MANY SUGGEST REPLACING THE RADIATOR WHEN REPLACING THE WATER PUMP, AS PREVENTIVE MAINTENANCE DUE TO THE RADIATOR'S HIGH AND FREQUENT FAILURE. REPLACE THE RADIATOR AS PREVENTIVE MAINTENANCE?!? I WOULD RATHER NOT. A RADIATOR IS NOT AN OIL OR AIR FILTER. (2) UPPER NECK ON THE RADIATOR BROKE AND RELEASED MORE THAN A GALLON OF COOLANT, IN LESS THAN 50 FEET, IN THE FORM OF LIQUID AND STEAM. THE STEAM OBSCURED VISION ON THE DRIVERS SIDE OF THE VEHICLE. LUCKILY I WAS MAKING A RIGHT-HAND TURN INTO A PARKING LOT. (3) NO REPAIR AS OF YET. THE FAILURE OF THE RADIATOR OCCURRED AT APPROXIMATELY 11:00 AM. I MADE IT HOME AT 12:05 P.M. I CALLED THE LOCAL BMW PARTS DEPARTMENT (ONE HOUR AND THIRTY MINUTES AWAY) TO ARRANGE TO PAY FOR THE RADIATOR BY CREDIT CARD AND THEN HAVE THE PART LEFT WITH ONE OF THE SALESPERSONS, BECAUSE THE PARTS DEPARTMENT CLOSES AT 1:00 P.M. BUT THEY NO LONGER ACCEPT CREDIT CARD PURCHASES OVER THE...

BUCKLE ON THE SEAT BELT IS IN A DEPRESSED POSITION, PREVENTING THE LATCH FROM LOCKING. CONSUMER TOOK THE VEHICLE TO THE DEALER, WHO SAID IT WOULD COST $400.00 TO REPAIR SEAT BELT BUCKLE. *AK THE SET BELT LATCH WOULD BECOME CONTINUOUSLY DEPRESSED IN WHICH IT WOULD NOT SPRING BACK AND WOULD NOT CONNECT INTO THE LATCH. *SC

THE FRONT STRUT SPRING PERCH FAILED ON MY 1997 MODEL BMW 540I. THE PERCH CUT INTO TIRE. HIS HAPPENED AT LOW-SPEED, SO NO INJURIES RESULTED (LUCKILY).MW NA HAS ISSUED A RECALL, BUT MY VEHICLE SUPPOSEDLY IS NOT COVERED, I THINK IT MISSED BY TWO MONTHS. MY BUILD DATE IS 08/96. I CONTACTED BMW NA ON 6/21/04 AND SPOKE TO RYAN, I WAS TOLD THE VEHICLE DID NOT QUALIFY FOR THE RECALL AND THAT BMW NA WOULD NOT REIMBURSE ME FOR THE DAMAGES. I HAVE DIGITAL PICTURES OF THE STRUT THAT I CAN EMAIL. I ALSO HAVE THE STRUTS THEMSELVES STILL IN MY GARAGE IF SOMEONE WOULD BE INTERESTED IN SEEING THEM. JOHN. *AK