2000 Audi A6 Complaints

HELLO! TODAY I WAS AT THE SAMS CLUB GAS STATION TO FILL UP MY VEHICLE, 2000 AUDI A6 WITH THE 4.2 ENGINE. WHEN I FINISHED, I WENT OVER TO THE DRIVER SIDE, WHERE IVE SEEN A HUGE AMOUNT OF GAS ON THE GROUND. THE FUEL WAS LEAKING REALLY BAD FROM MY CAR. THE SAM'S CLUB EVEN CALLED THE FIRED DEPARTMENT AND THE POLICE THERE TOO. IT LEAKED OUT A LOT COUPLE GALLONS FROM MY VEHICLE. THANKS GOD THE GAS STATION HAD A SMALL INCLINE SO I COULD NOTICE IT RIGHT BEFORE I WOULD DRIVE AWAY. JUST THINKING THAT I WOULD DRIVE AWAY AND SOMETHING SERIOUS WOULD HAPPEN IT SCARES ME. AS I UNDERSTAND A LOT OF AUDIS ARE RECALLED BECAUSE OF THIS ISSUE. MINE IS NOT UNDER THE RECALL. WHAT CAN I DO TO GET MINE UNDER THE RECALL TOO? PLEASE HELP ME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

AFTER FILLING GAS TANK, GAS BEGAN LEAKING AS A STEADY STREAM FROM LEFT FRONT SIDE OF GAS TANK, NEAR THE REAR DRIVER'S WHEEL WELL. OWNER CONTACTED AUDI DEALERSHIP AND AUDI OF AMERICA. OWNER PAID FOR DEALER INSPECTION TO DIAGNOSE LEAKING GAS ISSUE. DEALER STATED THE TANK WAS LEAKING AND NEEDED TO BE REPLACED. AUDI OF AMERICA CONTACTED OWNER ON 3/20/2014 AND STATED THE SERVICE MANAGER OF AUDI OF ANN ARBOR, MI HAD DECIDED THEY WOULD NOT COVER THE REPAIR DUE TO VEHICLE "MILEAGE AND AGE." AUDI OF AMERICA STATED SINCE VEHICLE WAS OUTSIDE OF RECALL RANGE (2001-2005 MY), THEY WOULD NOT ASSIST WITH REPAIRS. INDEPENDENT OWNER RESEARCH SHOWS MULTIPLE LEAKING GAS TANK ISSUES (BROKEN ROLLOVER VALVE NIPPLE) WITH THIS VEHICLE, AND MATCHING PART NUMBERS BETWEEN 2001-2005 MY GAS TANKS AND 2000 MY GAS TANK. *TR

FIRST INCIDENT MARCH 2006 LEAKY GAS TANK HAD TO BE REPLACED, COST TO US $2,249.27, AUDI DENIED RESPONSIBILITY. REQUESTED AUDI TO REPORT THIS ISSUE TO AUTHORITIES. SECOND INCIDENT, 7/30/13 (MILEAGE 163,016): VERY STRONG GASOLINE ODOR. THE MECHANIC REMOVED REAR SEAT AND FOUND FUEL STAINING ALL AROUND THE SENDING UNIT. FUEL TANK MUST AGAIN BE REPLACED. THIS WILL BE OUR THIRD TANK COUNTING THE ORIGINAL ONE INSTALLED AT THE FACTORY. IN 2008 AUDI ISSUED SAFETY RECALL CIRCULAR CODE: 2OL8/JY REVISED IN JANUARY 2009. MY FIRST FUEL TANK FAILURE OCCURRED 2 YEARS BEFORE THE RECALL. THE AUDI RECALL COVERS MODEL YEARS 2001 THROUGH 2005. MY CAR IS 2000 WITH THE SAME DEFECT AS IN LATER MODELS. 2000 MODEL SHOULD HAVE BEEN INCLUDED IN THE RECALL. I FIND IT INCREDIBLE THAT AUDI DID NOT KNOW THAT THE IDENTICAL SAFETY DEFECT WAS IN THE 2000 MODEL. THE 2006 FUEL TANK AND PARTS WERE PURCHASED NEW FROM AUDI AND SHOULD BE THE NEWER DESIGN FUEL TANK (IF THERE HAD BEEN ANY REDESIGN BY THEN). ALSO, AS...

LAST MONTH I FILLED UP MY TANK & AFTER DOING SO HAD A VERY STRONG SMELL OF GAS IN THE CABIN. I TOOK IT TO AN INDEPENDENT MECHANIC & HE TOLD ME THAT I HAVE A BROKEN ROLLOVER VALVE. TO REPLACE THE TANK COSTS $2500. THIS IS POTENTIALLY A VERY SERIOUS ISSUE GIVEN LEAKING GAS! AFTER RESEARCH I FOUND THERE IS A RECALL TO REINFORCE THE VALVE WITH EPOXY. UNFORTUNATELY THE RECALL IS FOR 2001-2004 MODELS & MINE IS A 2000. THE ISSUE ON MY 2000 IS THE EXACT SAME TANK/VALVE. I NEXT CONTACTED AUDI CUSTOMER SERVICE TO GET A CASE # HOPING THEY'D TAKE RESPONSIBILITY. THEY CREATED THE CASE BUT TOLD ME UNTIL THE ISSUE IS VERIFIED BY AN AUDI DEALER THEY CAN'T DO ANYTHING. DOING SO WOULD COME WITH NO GUARANTEES. I CALLED THE DEALER & THEY SAID THE COST OF A DIAGNOSTIC IS $109. SO I TOOK IT TO THE DEALER FOR A DIAGNOSTIC TO VALIDATE THE INDEPENDENT MECHANIC?S ANALYSIS. THE DEALERSHIP CALLED TODAY & CONFIRMED THE ISSUE FROM THE INDEPENDENT. COST TO PATCH IS $452+TAX (RATHER THAN COMPLETELY REPLACE THE TANK...

WHEN MOVING THE STEERING COLUMN UP OR DOWN SMOKE COMES OUT OF THE STEERING COLUMN AND GET A BURNING SMELL ON THE PASSENGER SIDE. *TR